Cleaning, Maintenance And Storage; Battery Care; Motor Maintenance; Storage - BH ATOM Manuel

EN
USER MANUAL

8. CLEANING, MAINTENANCE AND STORAGE

Do not use high-pressure washers or jet stream cleaners, as they may cause
ATTENTION water ingress, damaging the system, the motor, the display panel or the battery.
If water enters one of these units, ask an authorised dealer to check your bicycle.

8.1 Battery Care

Keep the battery clean. Use a damp and properly wrung out cloth to clean dirt from the battery case. Do not pour
water directly onto the battery, e.g. with a hose.
Do not clean the contacts by polishing them with a file or using a wire, etc.
ATTENTION
Otherwise, it may cause failures.

8.2 Motor Maintenance

Because the motor is a precision machine, do not disassemble it or exert excessive force on it (e.g. do NOT hit
this product with a hammer).

8.3 Storage

Keep the bicycle in a place that is:
• Flat and stable
• Well ventilated and dry
• Protected from the elements and direct sunlight

8.4 Prolonged Storage

If you are going to store the bicycle for a prolonged period (1 month or more), remove the battery and store
it as follows.
• Make sure that the remaining battery capacity is above 50% and then store it indoors, in a cool
(10 to 20°C) and dry place.
• Check the remaining battery capacity once a month, as the battery is slowly discharged while
in storage. If the capacity is below 50%, charge it until it is above 50%.
• When using it again after a prolonged period of storage, be sure to charge the battery before use.

9. TECHNICAL SPECIFICATIONS

9.1 Motor

• Direct Current Brose Motor.
• 250 W power. / Maximum assistance speed 25 km/h.
• System voltage: 36 V.
•

9.2 Battery

• Lithium-ion battery.
• Battery voltage: 36 V.
• Capacity: 500 Wh or 600 Wh (depending on version).
•

9.3 Central Display Panel

• USB type: USB 2.0.
• Output current; max. 1,000 mA.
48
ATOM & ATOMS ATOM & ATOMS

10. FAQs

What is the maximum speed of this bicycle?
It depends on the user. There is no maximum speed. However, at speeds over 25 km/h, the pedal assistance
provided by the motor is disabled. This restriction on assistance is a legal requirement for pedal-assist bicycles,
according to European regulation EN 15194:2017.
The NITRO and AWD models are an exception as they are not approved as pedal-assist bicycles. The maximum
assistance speed is limited to 45 km/h in NITRO models, which are approved as motorcycles.
Isn't a BH bicycle extremely heavy?
Not really, if you consider that the weight of BH bicycles is between 15 kg and 30 kg, depending on the model,
making them the lightest electric bicycles on the market. Pedal assistance means that a BH bike weighs 3-6 kg
more than a standard bicycle with the same characteristics, because of the battery and the motor.
Should I take any additional precautions when riding a BH bike instead of a standard bicycle?
No, but we recommend paying special attention when starting the BH, due to the additional thrust provided by
the motor. So we recommend starting it in 30%/ECO mode, with a short gear ratio (higher gears).
Do I have to stop every time that I want to activate pedal assistance?
No, pedal assistance can be activated while riding the bicycle, although it is not advisable because it may cause
a distraction. The only requirement to properly activate assistance is to stop pedalling for two seconds after
pressing the ON/OFF button,
thus enabling all of the elements of the electrical system to be properly activated.
Can I stand over the bicycle when I stop at traffic lights?
Yes. The motor will remain inactive as long as no pressure is being applied on the pedal. The greater the force
applied on the pedal, the greater the forward thrust on the bicycle. This is the result of the magnetic torque
sensor continuously reading the force applied on the pedal.
How often should I take the bicycle to a BH store for maintenance?
The other components require similar maintenance to the components of a standard bicycle, depending
on the frequency of use of the bicycle and how well it is looked after.
What should I do when I don't plan to use the bicycle for a long period of time?
We recommend charging it to 50% before storing it for a long time. We also recommend checking its charge
level every three months and keeping it above 50%.
Why is the range reduced when it is frosty or very cold?
This is normal; below -5ºC the performance of the battery is reduced. This does not cause any problems
or damage the battery, it simply means that it cannot be fully discharged, thus reducing the range of the bicycle.
Can I purchase additional batteries?
Yes, additional batteries are available at BH stores. If a longer range is required and it will not be possible
to charge the battery between two journeys, we recommend purchasing a second battery that is suitable
for the BH bicycle that you purchased.
Can I use the battery from my wife's electric bicycle?
Yes, provided that the battery is from a BH bicycle that is compatible with the model purchased by you. If the battery
is from another, non-compatible electric bicycle, it should not be used in the BH bike. This could damage
the assistance system beyond repair and would invalidate the warranty.
Should I use a helmet?
Whether or not a user has to wear a helmet depends on the law in each country, but we recommend using them
for safety reasons.
Should I have third-party liability insurance?
No, insurance is not compulsory, except for NITRO models.
Is there a minimum age required for using a BH bike?
No, any user can ride a BH bike, except for NITRO models.
EN
USER MANUAL
49