DeWalt DXGNR 7000 Manuel D'instructions page 9

Assembly
Unpacking
•
Remove all packaging material.
•
Remove separate accessory kit box.
•
Remove generator from carton.
Accessories
Check contents against the list in Table -1. If any parts
are missing or damaged, or if any problems occur during
assembly, call the Generator Helpline at 1-888-431-6871.
Table -1. Contents
Item
Generator
Owner's Manual
Product Registration Card
(English, Spanish, and French)
Service and Emissions Warranty
Liter SAE 30 Oil
Battery Charger (electric start models)
Wheel (A)
Frame Foot (B)
Handle Assembly (C)
Axle (D)
Hardware Bag
Rubber Foot (E)
Hair Pin (F)
1/2" Flat Washer (G)
M8 Carriage Bolt (H)
M8 Bolt (long) (J)
M8 Hex Flange Nut (K)
Axle Bracket (L)
M6 bolt (M)
Install Accessory Kits
The generator requires some minor assembly before
use.
Tools Required
Obtain the following tools:
•
Two 8mm, 10mm, 12mm and 13mm box wrenches
Owner's Manual for Portable Generator
Install Wheel Kit (If Equipped)
The wheels are specially designed to enhance portability.
NOTICE:
Slide M6 bolt (M) through holes in frame rail. Install into axle
1.
bracket (L).
Slide axle (D) through axle bracket (L), wheel (A), and into
2.
½" flat washer (G). Insert hair pin (F) through axle (D).
Qty.
1
1
3
1
K
1
A
1
2
2
1
1
Install frame foot and rubber bumpers.
Slide rubber foot (E) through frame foot (B). Install locking
1.
2
flange nuts (K).
Slide M8 bolt (J) through holes in frame rail. Slide frame foot
2.
2
(B) onto M8 bolts. Install locking flange nuts (K).
2
Install Handle
2
Slide M8 carriage bolt (H) through handle bracket and han-
1.
4
dle assembly (C) by first inserting the bolt through the
8
square hole in the handle assembly (C).
Install M8 flange nut (K).
2.
2
Battery Replacement/Connection
4
NOTICE:
lose some charge when not in use for prolonged periods
of time. If battery is unable to crank engine, plug in the
12V charger included in the accessory box (see
Charging the Battery (electric start units only)
IMPORTANT: Running the generator does not charge
battery.
WARNING
tive battery cable when working on unit. Failure to do so
could result in death or serious injury.
The wheels are not intended for over-
the-road use.
J
M
B
D
L
The battery shipped with the generator
has been fully charged. A battery may
Accidental Start-up. Disconnect the
negative battery cable, then the posi-
K
H
C
F
G
E
000757
5