Electric Connection - Thule TO 8000 Instructions

1. PREPARATION OF THE AWNING
- Open the awning about 50cm.
- Remove both plastic end caps after removing the screws (fig. 3 and 4).
- Close the awning till about 10cm and secure the front profile by wrapping
two straps around the awning (fig. 5).
- Remove the right hand side (as you look at the awning) aluminium end
plate (fig. 6), remove all of the parts shown in fig 7 so that it looks as the
same as figure 8 then replace the end plate .
- Remove the left hand side aluminium end plate (fig. 9).
- Remove the screw from the end cap at the left hand side of the roller
tube. Press on the hinge part inside whilst removing the end cap from the
roller tube. (fig. 10 and 11).
2. INSTALLATION OF THE MOTOR
- Slide the motor with its end plate, till half way inside the roller tube (fig. 12).
- Slide the limit switch crown (b) into the tube and tighten the screw
DIN7982 4.2X38 in the previously drilled hole between the tube slot and
the fabric rope in order to fix the fabric (fig. 13).
- Now slide the motor completely into the roller tube. Make sure that the
two fins on the motor line up with groove in the limit switch crown (fig. 14).
- Fix the end plate with the three screws. Ensure that the wires do not
interfere (see fig. 1).
- Fix the emergency handle (i) with the screw (g) and the washer (h) to
the end plate (fig. 15).

3. ELECTRIC CONNECTION

You always have to connect to the 230V supply. If there is no 230V
supply available, then you should use an inverter to convert the voltage.
Connection of the inverter, see further on.
- Connect the wires as shown on the diagram fig. 25.
- Place an electric cable 2 x 0.75 mm
- Place a 6A fuse in the conductor. In order to avoid short circuiting wait
before introducing the fuse until the electrical connection is completed.
- It's important to install the relay as shown as in the diagram, in order to
disconnect the current to the motor whilst driving. Install the relay so that
it is out of reach for anyone else.
4
2
+ earth.
5AP905-09