Door Glass Replacement; Care Of Glass - Napoleon High Definition Série Manuel D'installation Et D'opération

maintenance
EN

13.3 door glass replacement

WARNING
!
• Do not use substitute materials.
• Glass may be hot. Do not touch glass until cooled.
• Care must be taken when removing and disposing of any broken door glass or damaged components. Be
sure to vacuum up any broken glass from inside appliance before operation.
• Do not strike, slam, or scratch. Do not operate appliance with glass removed, cracked, broken, or scratched.
Replacement glass/frame assembly shall be replaced as a complete unit as supplied by the appliance
manufacturer.
Only available as an assembly complete with gasket. Glass not available separately.
Place the door frame down careful not to scratch the paint.
A.
Bend up the glass retainers being careful not to snap them.
B.
THIS TEMPLATE MUST BE USED WITH 38.1
Remove the glass from the frame.
C.
NOTE: Care must be taken when removing and disposing of any
broken glass or damaged components. Be sure
to vacuum up any broken glass from inside the
appliance before operation.
Center the gasketed glass inside the door
D.
frame with the thick side of the gasket facing
up.
Bend the glass retainers located along
E.
the edge of the door frame over the
gasket holding the glass in place making sure that the thick portion is
protruding past the retainer. Careful not to break the glass.

13.4 care of glass

WARNING
!
• Do not clean glass when hot! Do not use abrasive cleaners to clean glass.
Buff lightly with a clean dry soft cloth to remove accumulated dust or fi ngerprints. Clean both sides of the glass
after the fi rst 10 hours of operation with an ammonia-free glass cleaner.
note:
Vinegar-based glass cleaners have demonstrated an ability to provide a clean, streak free glass surface.
Thereafter, clean as required. If the glass is not kept clean permanent discoloration and / or blemishes may
result. Contact you local authorized dealer / distributor for complete cleaning instructions.
Razor blades, steel wool, or other metallic objects must not be used on both surfaces of the glass. Doing so
can remove a thin layer of metal from the razor blades, steel wool, or other metallic objects that may then be
deposited onto the coating. This can result in a discoloured stain or scratch-like mark. More importantly, this can
scratch the glass surface, thereby reducing its strength.
Do not operate the appliance with broken glass, as leakage of fl ue gases may result.
Contact your local authorized dealer / distributor for complete cleaning instructions.
If the glass should ever crack or break while the fi re is burning, do not open the door until the fi re is out. Do not
operate the appliance until the glass has been replaced. Contact you local authorized dealer / distributor for
replacement parts. DO NOT SUBSTITUTE MATERIALS.
This appliance is factory equipped with 5mm ceramic glass. Use only replacement parts as supplied by the
appliance manufacturer. DO NOT SUBSTITUTE MATERIALS.
44
W415-1596 / B / 10.12.18
38.1
38.1.1
GASKET
GLASS
RETAINER
GASKET
GLASS
GLASS
RETAINERS
5.1A
GLASS