Chapter 14 Extraordinary Maintenance; Chapter 15 Decommissioning; Chapter 16 Dismantling / Demolition; Chapter 17 Emergency Situations - Columbus KS 51 BM 45 Mode D'emploi

Vacuum Sweeper
KS 51|BM 45 – KS 71|BM 60
REPLACING THE DUST FILTER:
Check the dust filter Detail 1 Fig. 8 every 40 - 70 working hours or as necessary. Take the filter out of its seat
by unscrewing bolt Detail 2 Fig.8. Position the new filter and tighten the bolt Detail 2 Fig. 8 making sure the
filter-pressure bracket Detail 3 Fig.8 is sufficiently compressed.
___________________________________________________________________________________________________
FOR OPERATIONS RELATIVE TO THE BATTERY, FOLLOW THE INSTRUCTIONS DESCRIBED IN CHAPTER SAFETY RULES AND
REGULATIONS IN THE PARAGRAPH RESIDUAL RISKS FOR BATTERY POWERED MODELS.
___________________________________________________________________________________________________
So that the batteries last as long as possible, recharge them as soon as the volt meter goes into the red zone. If the accumulators go excessively
low, the performance is reduced and their life is consequently shorter.
At each charging cycle, check the level of the sulphuric acid solution in the elements of the battery. Top up with distilled water if necessary.
Always complete the recharge cycle without interrupting it.
Ask the Dealer or Supplier to send qualified personnel to check the electric motor brushes every 200 working hours.
BATTERIES, NEW BATTERIES INCLUDED, THAT ARE ALLOWED TO RUN COMPLETELY FLAT CANNOT BE RE-CHARGED.
___________________________________________________________________________________________________
EXTRAORDINARY MAINTENANCE MEANS ANY OPERATION NOT INCLUDED IN THE CHAPTER ROUTINE MAINTENANCE. ALL
SPECIAL MAINTENANCE OPERATIONS HAVE TO BE MADE BY MANUFACTURER'S OR DEALER'S QUALIFIED STAFF ONLY.
___________________________________________________________________________________________________
Remove the batteries from their housing and store them in a cool ventilated place. The batteries, even if not used, must be recharged every 30
- 40 days. After the same period check the level of sulphuric acid solution and top up if necessary. Thoroughly clean the filters and waste
container.
___________________________________________________________________________________________________
THE DESTRUCTION OR DEMOLITION OF THE MACHINE MUST BE CARRIED OUT BY THE OWNER WITH TOTAL
OBSERVATION OF THE LAWS IN FORCE. IT IS ADVISABLE TO UTILISE COMPANIES SPECIALISED IN THIS SECTOR.
___________________________________________________________________________________________________
In any kind of emergency situation such as, for example, if You have accidentally driven the sweeper over current-carrying cables on the
floor which have wound around the main or side broom, or there are strange noises coming from inside the machine or motor, or You have
accidentally picked up incandescent materials or flammable liquids, chemical products in general, poisons, etc.
YOU WILL HAVE TO:
1 - Release the lever to stop traction.
2 - Turn engine off in the explosion engine models, putting the accelerator lever, that is on the engine, onto STOP; or in the
case of battery powered sweepers, turn the start key, on the control panel, from right to left.
CHAPTER 14 – EXTRAORDINARY MAINTENANCE
CHAPTER 15 – LEAVING THE MACHINE UNUSED FOR LONG PERIODS
27
CHAPTER 16 – DISMANTLING/DEMOLITION
CHAPTER 17 – EMERGENCY SITUATIONS