Table des Matières
Publicité
Liens rapides
FM-1500HD,
Operator's Manual
1700HD,
Manuel d'utilisation
Libro de Instrucciones
2000, & 2300
READ THIS BOOK
This book has important information for the use and safe operation of this machine. Failure to read
this book prior to operating or attempting any service or maintenance procedure to your Clarke
machine could result in injury to you or to other personnel; damage to the machine or to other property
could occur as well. You must have training in the operation of this machine before using it. If you
cannot read English, have this manual explained fully before attempting to operate this machine.
All directions given in this book are as seen from the operator's position at the rear of the machine.
®
For new books write to: Clarke
, 2100 Highway 265, Springdale, Arkansas 72764.
®
Clarke
Form No. 70447A
2/08
Printed in the U.S.A.
Publicité
Table des Matières
Manuels Connexes pour Clarke FM-1500HD
Sommaire des Matières pour Clarke FM-1500HD
- Page 1 This book has important information for the use and safe operation of this machine. Failure to read this book prior to operating or attempting any service or maintenance procedure to your Clarke machine could result in injury to you or to other personnel; damage to the machine or to other property could occur as well.
-
Page 2: Table Des Matières
Maintenance of the Machine ................22 Sub Assemblies Available ................... 23 Accessories Available ..................23 Assembly drawing....................24 Parts List ....................25 Wiring Diagram 1500 HD, 1700 HD, 2000 ............26 Wiring Diagram 2300 ..................28 Page 2 Clarke ® Operator's Manual FM-1500HD, 1700HD, 2000, & 2300... - Page 3 Todas las indicaciones de dirección dadas en este libro están dadas desde la posición del operador en la parte de atrás de la máquina. Puede Ud. conseguir libros suplementarios dirigiéndose a su distribuidor Clarke. Indice Instrucciones de seguridad para el operador ..............6 Mandos ..........................
- Page 4 Toutes les indications de direction figurant dans ce manuel sont visualisées depuis la position de l’opérateur, à l’arrière de la machine. Pour toute commande de manuels, adressez-vous à votre revendeur Clarke. Consignes de sécurité pour l’opérateur ................8 Commandes ........................11 Préparation de la machine avant la mise en service ............
-
Page 5: Operator Safety Instructions
Read all machine labels before attempting to operate. Make sure all of the labels and instructional information are attached or fastened to the machine. Get replacement labels and decals from your authorized distributor. NOTE: This machine is intended for commercial use. ® Clarke Operator's Manual FM-1500HD, 1700HD, 2000, & 2300 Page 5... - Page 6 ¡ CUIDADO ! Si usa una máquina antes de que esté completamente montada, corre el peligro de herirse o causar daños materiales. No opere la máquina antes de que esté completamente montada. Compruebe cuidadosamente el estado de la máquina antes de cada utilización. Page 6 Clarke ® Operator's Manual FM-1500HD, 1700HD, 2000, & 2300...
- Page 7 Compruebe que todos los adhesivos y las instrucciones estén colocados en los sitios previstos. Si es preciso, haga un nuevo pedido a su distribuidor Clarke. AVISO ! No use la máquina como escabel o mueble. Corre el peligro de causar lesiones o daños materiales.
- Page 8 Tous les travaux effectués par des techniciens qualifiés. Bien veiller à ce que les fixations soient correctement serrées. Effectuer les réglages conformément aux indications figurant dans le manuel. Page 8 Clarke ® Operator's Manual FM-1500HD, 1700HD, 2000, & 2300...
- Page 9 “ATTENTION” près de la surface que vous nettoyez. AVERTISSEMENT: Cette machine est lourde. Faites-vous aider pour la transporter ou pour la déplacer. NOTE: Cette machine est destinée à un usage commercial. ® Clarke Operator's Manual FM-1500HD, 1700HD, 2000, & 2300 Page 9...
-
Page 10: The Controls
NOTE: To prevent damage to the brush or pad driver, remove the accessory while not in use. To connect a solution tank, follow the instructions given with the tank. Figure 4 Page 10 Clarke ® Operator's Manual FM-1500HD, 1700HD, 2000, & 2300... -
Page 11: Preparacion De La Maquina Para Trabajar
Pour connecter un réservoir de solution, suivre les instructions fournies avec le réservoir. Para conectar un depósito de solución siga las instrucciones entregadas con el depósito. ® Clarke Operator's Manual FM-1500HD, 1700HD, 2000, & 2300 Page 11... -
Page 12: Extension Cords
WARNING: If you use an extension cord, use an extension cord with minimum wire size 12 AWG. Do not use an extension cord longer than 50 feet. Do not join two extension cords. Page 12 Clarke ® Operator's Manual FM-1500HD, 1700HD, 2000, & 2300... - Page 13 6 mm². ningún añadido de más de 15 N’utilisez pas de rallonge metros de largo. Nunca d’une longueur supérieure à conecte dos añadidos. 15 m. Ne raccordez jamais deux rallonges. ® Clarke Operator's Manual FM-1500HD, 1700HD, 2000, & 2300 Page 13...
- Page 14 Authorized Broche de mise à la terre person to make the connection. Fiche Schuko Encoches latérales pour mise à la terre Figure 6b Page 14 Clarke ® Operator's Manual FM-1500HD, 1700HD, 2000, & 2300...
-
Page 15: Conexion Electrica
Si la prise ou le connecteur n’est pas adéquat, faire appel à un électricien ou à un technicien autorisé. ® Clarke Operator's Manual FM-1500HD, 1700HD, 2000, & 2300 Page 15... -
Page 16: How To Operate The Machine
Figure 9 eas on the floor surface. These areas can cause a dangerous condition for the opera- tor or other persons. Always put CAUTION signs near the area being cleaned. Page 16 Clarke ® Operator's Manual FM-1500HD, 1700HD, 2000, & 2300... -
Page 17: Mise En Marche Et Arrêt De La Machine
Abaisser le timon Verrouiller le timon dans la position la plus confortable NOTA: Siempre tenga el mango con ambas pour le travail (Voir fig. 9) manos. ® Clarke Operator's Manual FM-1500HD, 1700HD, 2000, & 2300 Page 17... -
Page 18: Accessories
Remove or blow dust and dirt from the motor frequently. Repairs If repairs to the gear unit or motor are needed, do not disassemble the gears and motor! Return the ma- chine to the nearest Clarke Service Branch or Clarke Authorized Service Center. Page 18 Clarke ®... -
Page 19: Mantenimiento De La Maquina
Une ponceuse ne peut etre utilisee que dans de bonnes conditions d'aeration. Para más información diríjase a su distribuidor Clarke. Pour de plus amples informations, veuillez contacter votre revendeur Clarke. MANTENIMIENTO DE LA MAQUINA... -
Page 20: Entretien
Mande la máquina a un centro de mantenimiento autorizado Renvoyer la machine dans un centre d’entretien agréé Clarke cada 12 meses para comprobarla. Clarke tous les 12 mois, afin de la faire vérifier. PALANCA DE BLOQUEO LEVIER DE VERROUILLAGE El sistema de bloqueo de la tobera puede aflojarse. Aprete de Le système de verrouillage du timon peut se relâcher. - Page 21 FM-1500HD, 1700HD, 2000, & 2300 Section II Parts and Service Manual (70447A) Clarke ® Operator's Manual FM-1500HD, 1700HD, 2000, & 2300 Page 21...
-
Page 22: Maintenance Of The Machine
Make sure all connections are tight. CAUTION: Keep all fasteners tight. Keep all Return the machine to a Clarke Service Branch or a Clarke adjustments according to specifi- Authorized Service Center for electrical repairs and testing. -
Page 23: Sub Assemblies Available
66102A Super Grip Drive Pad Assembly 37011A 37088A Solution Tank Assembly 508641 508641 508641 508641 Spray Buff Attachment 440570 440570 440570 440570 Lambswool Polishing Pad 495904 485904 465908 455908 ® Clarke Operator's Manual FM-1500HD, 1700HD, 2000, & 2300 Page 23... -
Page 24: Assembly Drawing
Clarke ® Floor Maintainer Models 1500HD, 1700HD, 2000, 2300 Assembly Drawing 2/08 Page 24 Clarke ® Operator's Manual FM-1500HD, 1700HD, 2000, & 2300... - Page 25 Coupling Drive 501141 Bushing - Link Arm 507302 Ring, Retaining 920110 Nut - -18 Elas Stop 902609 Bearing 980215 Washer-Wheel Thrust 167308 Ring-Retaining Parts List continued on page 26. ® Clarke Operator's Manual FM-1500HD, 1700HD, 2000, & 2300 Page 25...
- Page 26 Plate, Strain, Relief 911933 Clip, Terminal 911948 Clip, Terminal (FM-2300) 85817A Screw -18 x 920349 Nut ¼-20 Elas. Stop 506359 Plate, Fire & Sanding 911194 Lead Asm., White, (FM-2300) Page 26 Clarke ® Operator's Manual FM-1500HD, 1700HD, 2000, & 2300...
- Page 27 Wiring Diagram - 230V 50-60 Hz FM 1500HD, FM 1700HD, FM 2000 4/01 WARNING: Repairs by qualified personnel only. AVERTISSEMENT: Reparations par personnel specialise seulement. ADVERTENCIA: Unicamente personal calificado deberian hacer reparaciones. ® Clarke Operator's Manual FM-1500HD, 1700HD, 2000, & 2300 Page 27...
- Page 28 Floor Maintainer Wiring Diagram - 230V 50-60 Hz FM 2300 4/01 WARNING: Repairs by qualified personnel only. AVERTISSEMENT: Reparations par personnel specialise seulement. ADVERTENCIA: Unicamente personal calificado deberian hacer reparaciones. Page 28 Clarke ® Operator's Manual FM-1500HD, 1700HD, 2000, & 2300...
- Page 29 S-431 04 Molndal 2100 Highway 265 +46 31 706 73 00 Springdale, Arkansas 72764 (479) 750-1000 ALTO Norge A/S, Oslo (Norway) Bjornerudveien 24 N-1266 Technical Service +47 2275 1770 1-800-356-7274 ® Clarke Operator's Manual FM-1500HD, 1700HD, 2000, & 2300 Page 29...
- Page 30 Clarke repair station. Cost of the inspection and cleaning is the responsibility of the purchaser. Failure to comply with the annual inspection and cleaning requirement will void the additional two years warranty on the motor and gear unit.