Important - BWT P-PSC Notice D'installation Et Conseils D'utilisation

POURING THE CONCRETE:
Pour a slab 10 to 15 cm thick using reinforced concrete, 350 kgs/m3, on land that is stable, not
muddy or waterlogged and that is well consolidated. Depending on the surroundings, a concrete
mixing truck may be used to pour the underslab. First calculate the volume of concrete required as
follows:
BASE SURFACE AREA x 0.10 = VOLUME IN M3 (for a 10cm underslab)
If access is difficult, extension hoses (up to about 30 m ) or a concrete pump may be used.
Either lay down:
- 1 layer, smoothed immediately.
- 2 layers: 1 layer of concrete and subsequently a finishing screed (5 cm thick). When a
«LINER» is used for waterproofing the finish of surface must be impeccable. Make sure that
the upper surface of the main drain is flush with the finished surface of the underslab.

IMPORTANT:

The outer edge of the concrete underslab must not exceed the outer edge of the flanges jutting
back from the panels, otherwise it will not possible to drive the anchoring stake against the panel
into the support brace.
Therefore, ensure that the shuttering or formwork is at most 10 cm from the line marking the inner
pool wall or include a blank to leave a space for each supporting brace. After the PPP panels are
installed, round off all the connecting angles and the angles at the base of the panels with mortar
using a length of PVC tubing Ø 100 mm.
Panel - height 1500
Panneau h1500
Reinforced concrete slab
Radier armé
Jambe de force h1450
Support brace - height 1500
Coping
Margelle
Upper edge
Bord supérieur (arase bassin)
Panel - height 1200
Panneau h1500
Backfil
Remblai
Notched key
Clavette crantée
Support brace - height 1200
Jambe de force h1200
Achoring stake
Pieu d'ancrage
Concrete
Massif de béton
Pin
Goupille
Rounded corner R = 5 cm
Arrondi R=5 cm
Biocal underlay between
Feutre Biocol entre
the concrete slab and liner
le radier et le liner
Reinforced concrete slab
Radier béton armé
Blinding concrete (optional)
Radier de propreté (facultatif)
NOMINAL DIMENSIONS
COTE NOMINALE
36/48
2020/05 - Indice de révision : B - Code : 37101
CROSS SECTION VIEW OF THE COMPLETED ASSEMBLY
Decking
Dalles
~
70
10 60
PISCINES P-PSC