Publicité
Liens rapides
Owner's Instruction and Operation Manual
Model Numbers:
VG2520-P •
VG2520-L
•
Report Number: F19-487
Tested Per EPA Methods ALT-125, ASTM
E2515, ASTM E3053 and CSA B415
Mobile home / transportable building approved
* All Pictures In This Manual Are For Illustrative Purposes Only. Actual Product May Vary.
U.S. Environmental Protection Agency
© 2023 United States Stove Company, 227 Industrial Park Rd., South Pittsburg, TN 37380
VG2520-BP
VG2520-BL
R
THIS MANUAL IS SUBJECT TO CHANGE WITHOUT NOTICE.
CALIFORNIA PROPOSITION 65 WARNING:
This product can expose you to chemicals
including carbon monoxide, which is known to the
State of California to cause cancer, birth defects,
and/or other reproductive harm. For more
information, go to
853580J-0606M
www.P65warnings.ca.gov
Ph. 800-750-2723
Publicité
Manuels Connexes pour VOGELZANG VG2520-P
Sommaire des Matières pour VOGELZANG VG2520-P
- Page 1 Owner’s Instruction and Operation Manual Model Numbers: VG2520-P • VG2520-BP VG2520-L • VG2520-BL Report Number: F19-487 Tested Per EPA Methods ALT-125, ASTM E2515, ASTM E3053 and CSA B415 Mobile home / transportable building approved * All Pictures In This Manual Are For Illustrative Purposes Only. Actual Product May Vary.
- Page 2 The instructions pertaining to the installation of your wood stove comply with UL 1482-2022 and CAN/ULC S627:2023 standards. This manual describes the installation and operation of the Vogelzang, VG2520 wood heater. This heater meets the 2020 U.S. Environmental Protection Agency’s cordwood emission limits for wood heaters sold after May 15, cordwood.
- Page 3 INSTALLATION CHECKLIST CUSTOMER SERVICE 1-800-750-2723 ext 5050 Text to 423-301-5624 Email to: Customerservice@usstove.com COMMISSIONING CHECKLIST Failure to install and commission according to the manufacturer’s instructions and complete this checklist will invalidate the warranty. Please Print Customer Name: Telephone Number: Address: Model: Serial Number: Installation Company Name:...
- Page 4 ASSEMBLY INSTRUCTIONS FOR CUSTOMER SERVICE CALL: 800-750-2723 EXT 5050 TOOLS AND MATERIALS ASH PAN ASSEMBLY You will need a drill with a 1/8” bit to install sheet metal screws into connector pipe. A 5/16” socket/wrench or two brackets; Slide the ash pan into these brackets. manual.
- Page 5 ASSEMBLY INSTRUCTIONS FIREBRICK CONFIGURATION AIR DEFLECTOR ASSEMBLY Replace the Firebrick as shown in the illustration. rear of the unit. INSTALLATION SAFETY NOTICE • IF THIS STOVE IS NOT PROPERLY INSTALLED, A HOUSE FIRE MAY RESULT. TO REDUCE THE RISK OF FIRE, FOLLOW THE INSTALLATION INSTRUCTIONS.
- Page 6 INSTALLATION FOR CUSTOMER SERVICE CALL: 800-750-2723 EXT 5050 FLOOR PROTECTOR • For Canadian installations, where passage through a wall, or partition of combustible construction is desired, the installation must conform to CAN/CSA-B365. with an R-Value of at least 1.4 installed beneath it if the •...
- Page 7 INSTALLATION 1. Your stove does not draw steadily, smoke roll-out SECURING APPLIANCE’S ON A PEDESTAL occurs, wood burns poorly, or back-drafts occur TO THE FLOOR whether or not there is combustion present. not operate properly, suffer smoke roll-out when opened, or back-drafts occur whether or not there is combustion present.
- Page 8 INSTALLATION CHIMNEY CONNECTOR (STOVE PIPE) and “plugging” of the chimney. An inadequate draft will cause the appliance to leak smoke into the room through appliance and chimney connector joints. An uncontrollable Install burn or excessive temperature indicates an excessive crimped draft.
- Page 9 INSTALLATION 4. The draft caused by the tendency for hot air to rise will be increased with an interior chimney. Concrete Cap Fireclay Flue Liner With Airspace 1” Clearance requires regular inspection to ensure that it is not with Firestop obstructed thus blocking the draft, and it should be cleaned when used regularly.
- Page 10 INSTALLATION METHOD B - factory-built Solid-Pak chimney section with insulation of the chimney length and wall combustibles. Use sheet metal supports fastened securely to wall surfaces on fastening supports to chimney length, do not penetrate the The inner end of the Solid-Pak chimney section shall be sealed with a non-water soluble refractory cement.
- Page 11 OPERATION INSTRUCTIONS NEVER OPERATE THIS PRODUCT WHILE UNATTENDED CAUTIONS: HOUSE FIRE HAZARDS • DO NOT STORE WOOD ON FLOOR PROTECTOR, lower emissions generally result when burning air dried UNDERNEATH STOVEPIPE(S) ANYWHERE seasoned hardwoods, as compared to softwoods or too WITHIN CLEARANCES COMBUSTIBLE green or freshly cut hardwoods.
- Page 12 OPERATION INSTRUCTIONS vapor. The higher heating value is when water leaves the may not be fully cured and should be seasoned longer. combustion process completely condensed. In the case of woodstoves this would assume the exhaust gases are room temperature when leaving the system, and therefore only in your wood stove.
- Page 13 OPERATION INSTRUCTIONS For a cold start-up, place 4 to 5 pieces of newspaper into with 34 lbs of cordwood and close the door immediately. 5 minutes. After 5 minutes push in the air control to the medium position (midway between the “Low” and “Hi” during start-up and a high burn rate to increase the stove temperature.
- Page 14 OPERATION INSTRUCTIONS AIR TUBES WARNINGS: The air tubes assembled in this unit are designed to • NEVER OVERFIRE YOUR STOVE. IF ANY PART OF provide an accurate mix of secondary air to ensure the THE STOVE STARTS TO GLOW RED, OVER FIRING IS HAPPENING.
- Page 15 CHIMNEY MAINTENANCE NEVER OPERATE THIS PRODUCT WHILE UNATTENDED • Always check for creosote deposit once every two CAUTION: months and have your chimney cleaned at least once DO NOT OVERFIRE APPLIANCE. YOU ARE OVERFIRING a year. IF ANY PART OF THE APPLIANCE GLOWS RED. CLOSE •...
- Page 16 CHIMNEY MAINTENANCE areas can be dangerous. Make sure your stove gaskets GASKET CARE and chimney joints are in good working order and sealing WARNING: properly to ensure unintended exposure. It is recommended NEVER OPERATE STOVE WITHOUT GASKET OR WITH A DAMAGED OR BROKEN GASKET. OPERATING WITHOUT A GASKET OR DAMAGED GLASS CARE GASKET WILL RESULT IN DAMAGE TO YOUR STOVE...
- Page 17 HOW TO ORDER REPAIR PARTS For Parts Assistance Call: 800-750-2723 Ext 5051 or Email: parts@usstove.com manual will help to ensure the correct items are ordered. Before contacting customer service write down the model gathered you can contact customer service by phone 1-800-750-2723 Ext 5051 or Email parts@usstove.com. Model Information Model Number Serial Number...
- Page 18 REPAIR PARTS Part # Description 40292A 6” Flue Collar 88042 1/4” Rope Gasket 25845 891492 26060 Rear Shield 610926 Rear Ashpan 29243 Pedestal 29065 Pedestal Front Pedestal Base Weldment 610970 610968 Ashpan Housing 610883 Leg Weldment 25826 Hearth Plate 29216 Ash Pan 610068 Damper Slide Weldment 610066 Slide Retainer Weldment...
- Page 19 REPAIR PARTS Part # Description 88325 88138 Ceramic Fiber Board 86643 29247 Right Brick Panel 86645 29248 Left Brick Panel 24103A 40561 Ash Plug 891530A 89066A 891414A Half Firebrick To order parts: Call 1-800-750-2723 Ext 5051 or Email to: parts@usstove.com Part # Description 893240-VG Complete Door Handle...
- Page 20 SERVICE RECORD It is recommended that your heating system is serviced regularly and that the appropriate Service Interval Record is completed. SERVICE PROVIDER Before completing the appropriate Service Record below, please ensure you have carried out the service as described Service 01 Date: _______________________ Service 02...