Napoleon ULTRA CHEF 485 Instructions page 8

8
Operating The Grill
Initial Lighting: When lit for the first time, the gas grill emits a slight odor. This is a normal temporary condition
caused by the "burn-in" of internal paints and lubricants used in the manufacturing process and does not occur
again. Simply run the main burners on high for approximately one-half hour.
Main Burner Use: When searing foods, we recommend preheating the grill by operating all main burners
in the high position with the lid closed for approximately 10 minutes. Food cooked for short periods of time
(fish, vegetables) can be grilled with the lid open. Cooking with the lid closed will ensure higher, more even
temperatures that can reduce cooking time and cook meat more evenly. Food that has a cooking time longer
than 30 minutes, such as roasts, can be cooked indirectly (with the burner lit opposite to the food placement).
When cooking very lean meats, such as chicken breasts or lean pork, the grids can be oiled before pre-heating
to reduce sticking. Cooking meat with a high degree of fat content can create flare-ups. Either trim the fat or
reduce temperatures to inhibit this. Should a flare-up occur, move food away from the flames and reduce the
heat. Leave the lid open. See Your All Season Grill cookbook by Napoleon for more detailed instructions.
Direct Cooking: Place food to be cooked on the grill directly over the heat. This method is generally used for
searing or for foods that do not require prolonged cooking times such as hamburgers, steaks, chicken pieces,
or vegetables. The food is first seared to trap-in the juices and flavor, and then the temperature is lowered to
finish cooking the food to your preference.
Indirect Cooking: With one or more burners operating, place food to be cooked on the grill over a burner that
is not operating. The heat circulates around the food, cooking slowly and evenly. Cooking with this method is
much the same as cooking in your oven and is generally used for larger cuts of meats such as roasts, chickens
or turkeys, but can also be used for cooking foods that are prone to flare-ups or for smoking foods. Lower
temperatures and slower cooking times result in tender foods.
Rear Burner Use (If Equipped): Remove the warming rack prior to use, the extreme heat will damage the
warming rack. Cooking grids should also be removed if they interfere with the rotisserie. The rear burner is
designed to be used in conjunction with the rotisserie kit (included with most rear burner units) available from
your dealer. See the rotisserie kit assembly instructions.
To use the counterbalance - remove the rotisserie motor from the gas grill. Place the spit with meat being
cooked across the hangers inside the grill. The meat will naturally hang with the heavy side down. Tighten
the counterbalance arm and weight so the arm is facing up. Slide the counterweight in or out to balance the
load and tighten in place. Re-install the motor and begin cooking. Place a metal dish underneath the meat to
collect drippings for basting and naturally delicious gravy. Basting liquid may be added as required. To seal in
juices, first operate rear burner on high until brown, then reduce the heat to thoroughly cook foods. Keep the
lid closed for best results. Your roasts and fowl will brown perfectly on the outside and stay moist and tender
on the inside. For example, a 3 pound chicken on the rotisserie will be done in approximately 1½ hours on
medium to high. See 'Your all Season Grill' cookbook by Napoleon for more detailed instructions.
WARNING!
components unless cleaned regularly. When finished cooking disassemble rotisserie components, wash
thoroughly with warm soapy water and store indoors.
Flame Side Burner Use (if equipped): The side burner can be used like any stove top burner, for gravies, soups
etc. For best performance, the gas grill should be located with the side burner protected from the wind.
WARNING!
only.
Infrared Side Burner Use(if equipped): The gas grill should be located so that the side burner is protected from
the wind, because the wind will adversely affect its performance. The side burner lid needs to be removed
when cooking. Place the lid in the enclosure door.
The side burner is equipped with a cast iron cooking grid which can be positioned at two different heights. The
lower position can be used like any range top burner, for gravies, soups, etc. The higher position is for searing
meats. (see instructions located on side burner lid).
WARNING!
WARNING!
WARNING!
www.ultrachefgrills.com
Barbecue sauce and salt can be corrosive and will cause rapid deterioration of the gas grill
Never grill food directly on the side burner grate. It is designed for use with pots and pans
Do not close the side burner lid while it is operating or hot.
Do not adjust cooking grid while hot or operating.
Do not use side burner to deep fry foods as cooking with oil can create a dangerous situation.