Hydraulic Safety; Fire Prevention - Oregon OR25TBS-1 Manuel D'instruction

Safety Information

Hydraulic Safety

The hydraulic system of your log splitter requires careful inspection along with the mechanical parts . Be sure to replace
frayed, kinked, cracked, or otherwise damaged hydraulic hoses or hydraulic components .
DANGER
• NEVER check for leaks of hydraulic fluid with your hand . Fluid escaping from a small hole can be almost invisible . Escaping
fluid under pressure can have sufficient force to penetrate skin causing SERIOUS INJURY or even DEATH . Leaks can be
safely detected by passing a piece of cardboard over the suspected leak and looking for dis- coloration .
• ALWAYS seek professional medical attention immediately if injured by escaping hydraulic fluid . Serious infection or reaction
can develop if proper medical treatment is not administered immediately .
WARNING
• NEVER remove the cap from the hydraulic tank or reservoir while the log splitter is running . The tank could contain hot oil
under pressure which could result in serious injury .
• NEVER adjust the hydraulic valve . The pressure relief valve on your log splitter is preset at the factory . Only a qualified
service technician should perform this adjustment .
CAUTION
• ALWAYS be sure to relieve all pressure by shutting off the engine and moving the valve control handle back and forth should
it become necessary to loosen or remove any hydraulic fitting .

Fire Prevention

WARNING
• NEVER operate your log splitter near a flame or spark, or smoke during operation . Hydraulic oil and gasoline are flammable
and can explode .
• NEVER fill the gas tank while the engine is hot or running. Allow the engine to cool before refueling.
• ONLY refuel your log splitter in a clear, well ventilated area with no gas fumes or spilled gas.
• ALWAYS replace the gas cap securely.
• If gasoline has spilled, move the log splitter away from the area of the spill and avoid creating any source of ignition
until the spilled gas has evaporated.
• ALWAYS clean wood debris from the engine, muffler and beam.
• ALWAYS store gasoline in an approved, tightly sealed container and away from heating appliances. Store the
container in a cool, dry place.
CAUTION
• ALWAYS drain the fuel tank prior to storage to avoid the potential fire hazard.
10