Camp Chef PG24CL Manuel D'instructions page 8

HOPPER CLEAN-OUT KNOB ASSEMBLY INSTALLATION
Hand tighten the hopper clean-out knob as shown in Fig 16.
PG24-9 (1)
PULLOUT KNOB
FIG. 16
BURNER CLEAN-OUT
Before each use the burner should be cleaned out by lifting
the pullout lock and pulling the clean-out port knob on the
right side of the grill to open the burner clean-out. This will
allow the ash from previous use to fall into the cup under
the grill. The cup should be removed and emptied and then
reinstalled before each use.
Never Operate the Pellet grill without the ash cup in place.
Make sure the burner clean-out port is closed and locked
before starting the grill.
Never open the burner clean-out port when the grill is hot.
After cleaning out the burner make sure to close the burner
clean-out by pushing the clean-out port knob in on the right
side of the grill. Make sure to lift the pullout lock and push
the clean-out port knob all the way in and lock in place
with the pullout lock. Every 50 hours of use, remove the grill
grates, grease tray, and heat deflector and clean the inside
of the grill. If you notice a lot of ash blowing around in the
grill it is time to vacuum it out.
FIG. 14
CLEANOUT PORT CLOSED
FIG. 15
CLEANOUT PORT OPEN
DANGER
FILLING THE AUGER TUBE
CAUTION: ONLY USE THE FEED SETTING WHEN HOPPER HAS
RUN OUT OF PELLETS. FEED SETTING IS NOT FOR NORMAL USE.
The first time you use your grill or any time the hopper has
ran out of pellets you will need to fill the auger tube. This
simply means you must fill the auger tube with pellets
until pellets reach the burner. This is done by selecting
FEED from the main menu. This will turn the auger on and
the controller will display "FEED". The auger will remain
on for no more than 7 minutes. This is ample time for the
pellets to reach the burner. It is easiest to open the burner
clean-out by pulling the knob on the right side of the grill.
Once you hear pellets dropping into the cup you can close
the clean-out port by pushing the knob on the right side of
the grill and then select your cooking temperature. (Never
operate grill without the ash cup in place). Always make
sure the burner clean-out port is closed by pushing in the
knob on the right side of the grill before selecting any of the
cook settings. Never open the burner clean-out port when
the grill is hot.
APP QUICK START GUIDE
1. Download the Camp Chef APP from the Apple APP store or
Android Play Store.
2. Turn the Grill controller on using the main power switch.
3. Open the Camp Chef APP and follow the setup instructions for
connecting the grill to your home 2.4 GHz WiFi network.
Warning - Do NOT leave this appliance unattended while
in use. The user must remain in the immediate area of the
product and have a clear view of the product at all times
during operation.
Note - Some functions are only available from the controller.
If attempting to start the grill from the APP it will prompt
you to confirm starting the grill from the controller.
Temperature and Smoke settings can be adjusted from the
APP. Shutdown can also be performed from the APP.
For more information visit https:/www.campchef.com/app
CONTROLLER EXPLANATION
POWER SWITCH
Used to turn the main power onto the pellet grill. "O" is Off.
"-" is On. See Fig. 17
CLEANOUT PORT CLOSED
Fig. 17
CONTROLLER FUNCTIONS
Rotate the dial to scroll through menus, adjust temperature,
or smoke settings. Press the dial to select.
COOKING GRA
CLEANOUT PORT OPEN