Safety; Intended Use; Microbiological Examination Of Decentralized Disinfectant Dispensers - Ecolab DG 1-II Notice D'utilisation

2

Safety

The
ATTENTION
No warranty for the unit function when using unvalidated products.
CAUTION
Safety warnings and emphases must be observed in all cases!
ATTENTION
2.1

Intended use

The DG 1-II is a mixing equipment for disinfectants.
It is used for the production of a ready-to-use disinfectant solution and has been developed,
designed and built exclusively for the industrial and commercial use. A private use of the
equipment is excluded.
It is part of the intended use of dosing system to follow the manufacturer´s instructions for
maintenance, service, repair and disposal.
The service life of the equipment according to the properly conducted maintenance work is
approximately 10 years . An audit (potentially followed by a general overhaul) is required
subsequently by the manufacturer or a specialist company.
2.2

Microbiological examination of decentralized disinfectant dispensers

The end user is responsible for the proper operation of the dosing device according to the
recommended process from the RKI "requirements for design, features and operation of
decentralized disinfectant dispensers "(Federal Health Bulletin 2004 47: 67-72.).
In the device manual the annual required hygiene-technical checks are described in section
related to maintenance.
If the end user requires to test for a situation-related hygienic-microbiological verification of
the dosing device Ecolab suggests the process described in RKI recommendation
"requirement on hygiene in cleaning and disinfection of surfaces" (Federal Health Bulletin
2004-47: 51-61, Item 4.5). Kindly follow the following process as described in
chapter 8.1 "Microbiological examination of decentralized disinfectant dispensers
417101158_DG1.docx
DG1-II system must be used with validated products
29
".
Rev. 07-01.16