Bosch Drive Unit Cruise Notice Originale page 33

OBJ_BUCH-1407-005.book Page 12 Tuesday, October 8, 2013 9:41 AM
Safety Notes
Read all safety warnings and
all instructions. Failure to fol-
low the warnings and instruc-
tions may result in electric
shock, fire and/or serious in-
jury.
Save all safety warnings and instructions for future refer-
ence.
The term "battery pack" used in these operating instructions
refers both to standard battery packs (battery packs with
holder on the bike frame) and to rack-type battery packs (bat-
tery packs with holder in the rear rack/carrier).
Keep the charger away from rain or moisture. The
penetration of water into a battery charger increases
the risk of an electric shock.
 Only charge eBike-approved Bosch lithium-ion battery
packs. The battery-pack voltage must match the bat-
tery-pack charging voltage of the charger. Otherwise
there is danger of fire and explosion.
 Keep the battery charger clean. Contamination can lead
to danger of an electric shock.
 Before each use, check the battery charger, cable and
plug. If damage is detected, do not use the battery
charger. Never open the battery charger yourself.
Have repairs performed only by a qualified technician
and only using original spare parts. Damaged battery
chargers, cables and plugs increase the risk of an electric
shock.
 Do not operate the battery charger on easily inflamma-
ble surfaces (e. g., paper, textiles, etc.) or surround-
ings. The heating of the battery charger during the charg-
ing process can pose a fire hazard.
 Vapours can escape in case of damage and improper
use of the battery pack. Provide for fresh air and seek
medical attention in case of complaints. The vapours
can irritate the respiratory system.
 Supervise children. This will ensure that children do not
play with the charger.
 Children or persons that owing to their physical, senso-
ry or mental limitations or to their lack of experience or
knowledge, are not capable of securely operating the
charger, may only use this charger under supervision
or after having been instructed by a responsible per-
son. Otherwise, there is danger of operating errors and in-
juries.
 Please read and observe the safety warnings and in-
structions enclosed in the operating instructions of the
Bosch eBike Systems
Charger
battery pack and drive unit/HMI, as well as in the oper-
ating instructions of your eBike.
 A short version of important safety warnings in English,
French and Spanish with the following content can be
found on the bottom side of the charger (marked with num-
ber 33 in the representation on the graphics page):
– For safe operation see manual. Risk of electric shock.
– Dry location use only.
– Charge only batteries of the Bosch eBike Systems. Oth-
er batteries may burst causing personal damage.
– Do not replace the plug assembly as risk of fire or elec-
tric shock may result.
Product Description and
Specifications
Product Features
(see page 6–7)
The numbering of the product features refers to the illustra-
tion of the battery charger on the graphics page.
20 Rack-type battery pack
21 Battery charge-control indicator
26 Standard battery pack
29 Battery charger
30 Charger socket
31 Plug-in connector
32 Ventilation openings
33 Safety warnings, charger
34 Charge connector
35 Socket for charge connector
Technical Data
Battery Charger
Article number
Rated voltage
Frequency
Output voltage
Charging current
Allowable charging temperature
range
Charging time
– PowerPack 300
– PowerPack 400
Number of battery cells
The values given are valid for a nominal voltage [U] of 230 V. For differ-
ent voltages and models for specific countries, these values can vary.
English–12
Charger
0 275 007 905
V~ 207 –264
Hz 47 –63
V
42
A 4
°C 0...+40
h 2.5
h
3.5
30 –40
0 276 001 YYY | (8.10.13)