Concept CAC150RK Manuel De L'utilisateur page 10

COMPRESSOR PARTS LIST COMPRESSOR PARTS LIST
Please refer to schematic drawing page 26.
PART NO. DESCRIPTION
CAC150RKC-1 CAC150RKC-1 Mini fl ashlight Mini fl ashlight
CAC150RKC-2 CAC150RKC-2 Flashlight holder Flashlight holder
CAC150RKC-3 CAC150RKC-3 Screw Screw
CAC150RKC-4 CAC150RKC-4 Rubber handle grip Rubber handle grip
CAC150RKC-5 CAC150RKC-5 Carry handle Carry handle
CAC150RKC-6 CAC150RKC-6 Screw Screw
CAC150RKC-7 CAC150RKC-7 Washer Washer
CAC150RKC-8 CAC150RKC-8 8. Cylinder head 8. Cylinder head
CAC150RKC-9 CAC150RKC-9 Air fi tting Air fi tting
CAC150RKC-10 Unloader tube CAC150RKC-10 Unloader tube
CAC150RKC-11 O-ring CAC150RKC-11 O-ring
CAC150RKC-12 Adjustable valve CAC150RKC-12 Adjustable valve
CAC150RKC-13 Valve plate CAC150RKC-13 Valve plate
CAC150RKC-14 Cylinder CAC150RKC-14 Cylinder
CAC150RKC-15 Screw CAC150RKC-15 Screw
CAC150RKC-16 Reed valve CAC150RKC-16 Reed valve
CAC150RKC-17 Piston ring CAC150RKC-17 Piston ring
CAC150RKC-18 Connecting rod CAC150RKC-18 Connecting rod
CAC150RKC-19 Bearing CAC150RKC-19 Bearing
CAC150RKC-20 Lock washer CAC150RKC-20 Lock washer
CAC150RKC-21 Crankcase cover CAC150RKC-21 Crankcase cover
CAC150RKC-22 Screw CAC150RKC-22 Screw
CAC150RKC-23 Crankcase CAC150RKC-23 Crankcase
CAC150RKC-24 Pressure switch CAC150RKC-24 Pressure switch
CAC150RKC-25 Crank CAC150RKC-25 Crank
CAC150RKC-26 Screw CAC150RKC-26 Screw
CAC150RKC-27 Clamp CAC150RKC-27 Clamp
CAC150RKC-28 Flat washer CAC150RKC-28 Flat washer
CAC150RKC-29 Rubber mount CAC150RKC-29 Rubber mount
CAC150RKC-30 Screw CAC150RKC-30 Screw
CAC150RKC-31 Rubber foot CAC150RKC-31 Rubber foot
BRAD NAILER MAINTENANCE BRAD NAILER MAINTENANCE
DAILY MAINTENANCE
CAUTION: Disconnect tool from air supply before cleaning and inspection. Correct
all problems before putting the tool back in service.
 Wipe tool clean and inspect for wear or damage. Use non-fl amable cleaning
solutions to wipe exterior of tool only if necessary. Do Not soak tool with clean-
ing solutions. Such solutions can damage internal parts.
 Inspect trigger and safety mechanism to assure system is complete and func-
tional: no loose or missing parts, no binding or sticking parts.
 Keep all screws tight. Loose screws can cause personal injury or damage the
tool.
 If the tool is used without an in-line oiler, place 2 drops of air tool oil into
the air inlet of the tool at the beginning of each workday and after about
1 hour of continuous use. Frequent but not excessive lubrication is required
for best performance. Oil added through the airline connection will lubricate all
internal parts. Use only air tool oil. Do not use oil with detergents or other
additives. These can cause damage through accelerated wear to the seals in
the tool.
PART NO. DESCRIPTION
CAC150RKC-32 Drain cock CAC150RKC-32 Drain cock
CAC150RKC-33 Pressure relief valve CAC150RKC-33 Pressure relief valve
CAC150RKC-34 Screw CAC150RKC-34 Screw
CAC150RKC-35 Washer CAC150RKC-35 Washer
CAC150RKC-36 Power cord CAC150RKC-36 Power cord
CAC150RKC-37 Air tank CAC150RKC-37 Air tank
CAC150RKC-38 Lock washer CAC150RKC-38 Lock washer
CAC150RKC-39 Air fi tting CAC150RKC-39 Air fi tting
CAC150RKC-40 Circuit board CAC150RKC-40 Circuit board
CAC150RKC-41 Screw CAC150RKC-41 Screw
CAC150RKC-42 Rotor CAC150RKC-42 Rotor
CAC150RKC-43 Spring CAC150RKC-43 Spring
CAC150RKC-44 Brush CAC150RKC-44 Brush
CAC150RKC-45 Brush holder CAC150RKC-45 Brush holder
CAC150RKC-46 Housing CAC150RKC-46 Housing
CAC150RKC-47 End cap CAC150RKC-47 End cap
CAC150RKC-48 Screw CAC150RKC-48 Screw
CAC150RKC-49 Accessory compartment CAC150RKC-49 Accessory compartment
CAC150RKC-50 Power cord clip CAC150RKC-50 Power cord clip
CAC150RKC-51 Pressure gauge CAC150RKC-51 Pressure gauge
CAC150RKC-52 Regulator assembly CAC150RKC-52 Regulator assembly
CAC150RKC-53 Motor shroud CAC150RKC-53 Motor shroud
CAC150RKC-54 Screw CAC150RKC-54 Screw
CAC150RKC-55 Power switch CAC150RKC-55 Power switch
CAC150RKC-56 Air hose CAC150RKC-56 Air hose
CAC150RKC-57 Screw CAC150RKC-57 Screw
CAC150RKC-58 Cover CAC150RKC-58 Cover
CAC150RKC-59 Cover CAC150RKC-59 Cover
CAC150RKC-60 Fuse holder CAC150RKC-60 Fuse holder
CAC150RKC-61 Washer CAC150RKC-61 Washer
CAC150RKC-62 Nut CAC150RKC-62 Nut
!