Spare Parts; Electrical Diagram; Disposal; Ec Declaration - PLYMOVENT DRAFTMAX BASIC Manuel D'installation

Symptom Problem
DraftMax Ultra only
Fan does not Downdraft
start running. table does not
function.
Irregular filter One of the
cleaning. filter
cartridges is
not being
cleaned.
Poor extraction No filter
capacity. cleaning.
Button No filter
MANUAL
does cleaning.
CLEANING
not react.
Buzzer emits Filter cartidges
polluted.
an interrupted
sound (2
seconds on - 2
seconds off).
Buzzer emits Filter cleaning
system does
an interrupted
not function.
sound (2
seconds on - 5
seconds off).
Buzzer keeps Operation hour
emitting counter does
continuous not start at 0
sound after after filter
filter replacement.
replacement.
8

SPARE PARTS

The following spare parts are available for the downdraft table
(refer to exploded view Fig. III on page 101):
Ref. Article no. Description
A 0040900020 Pressure regulator
B 0040000040 Pre spark arresters (set of 2)
C 0040100060 Spark arresters (set of 2)
D 0040000020 DuraFilter FCC 52
E 0040900270 Safety switch
F 0040900050 Fan wheel (60Hz/3400 rpm)
0040900060 Fan wheel (50Hz/2800 rpm)
G 0000101348 Motor 2,2 kW; 230-400V/3ph/50Hz
0040900080 Motor 3 kW (4 HP); 208-240V/480V/3ph/60Hz
(USA)
0040900090 Motor 3 kW (4 HP); 600V/3ph/60Hz (Canada)
0507060400/151013/G DraftMax Basic | DraftMax Advance | DraftMax Ultra
Possible cause Solution
PLC has not Wait 10 seconds
started up. after turning on the
main switch and try
it again.
No compressed Connect/repair
air available. compressed air
supply.
Automatic start/ Connect cable of
stop (movement automatic start/stop
sensor or (refer to Fig. 2.3A).
welding cable
sensor) not
connected.
Sensor of Replace sensor.
movement
sensor defective.
Welding cable Connect clamp of
sensor not welding cable sensor
mass
connected. to cable of
welding machine.
One of the Replace both
membrane membrane valves.
valves defective.
Membrane Replace both
valve(s) membrane valves.
defective.
PLC defective. Replace PLC.
Button Replace button
RESET
/ /
ALARM MANUAL ALARM MANUAL
.
CLEANING CLEANING
defective.
Button pushed Push button during
too short. at least 5 seconds.
Less than 20 Try again later.
operation hours Probably it is not
after downdraft necessary to clean
table came into the filter cartridges.
use.
Less than 20 Try again later.
operation hours Probably it is not
after filter necessary to clean
replacement/ the filter cartridges.
reset.
Pressure over Push button
the filter /
ALARM MANUAL
cartridges has to
CLEANING
reached 1500 suppress buzzer.
Pa. Subsequently push
the same button
during 5 seconds to
activate the filter
cleaning system.
No compressed Connect/repair
air available. compressed air
supply.
PLC has not been Reset PLC (refer to
reset. section 5.4).
Ref. Article no.
H 0040900210
0000102289
I 0040900200
0040900220
J 0040900240
K 0040900250
L 0040900230
M 0040900300
N 0040900170
O 0040900110
P 0040900170
Q 0040900100
R 0040900130
S 0040900120
T 0040900160
U 0040900040
V 0040900180
W 0046030010
X 0040900280
Y 0040900010
9

ELECTRICAL DIAGRAM

Refer to the separately supplied electrical diagram.
RESET
10

DISPOSAL

After life of the product, dispose it of in accordance with state or
local regulations.

EC DECLARATION

EC declaration of conformity for machinery
RESET
We, Plymovent Manufacturing B.V., Wezelkoog 11, 1822 BL
Alkmaar, the Netherlands, herewith declare, on our own
responsibility, that the products:
- DraftMax Basic
- DraftMax Advance
- DraftMax Ultra
which this declaration refers to, are in accordance with the
conditions of the following Directives:
- Machine Directive 2006/42 EC
- EMC2004/108 EC
- LVD 2006/95 EC
- ErP Directive 2009/125 EC
Alkmaar, the Netherlands, November 1, 2013
.
M.S.J. Ligthart
Product Manager
Description
Relay 100 C-16K (60Hz)
Relay MC2A
Thermal relay 4-6,3 A
Thermal relay 3,2-16 A
Fuse 1A (CC MR1)
Fuse 500 mA
Transformer UL 65 VA
PLC (Logo! 24RC)
Fuse 24V circuit 2A slow blow
Pressure difference switch 6-50 mBar
Fuse 24V circuit 2A slow blow
PC board control
Push button green incl. light
Push button black
Buzzer
Pressure gauge
Main switch
Safety valve compressed air tank
Compressed air presence switch
Pressure relief valve
EN - 15