Troubleshooting - Carson Gas Devil Mode D'emploi

g. Troubleshooting
Please read this before something happens.
Engine does not start
Problem
No spark in the spark plug
Spark plug
Magneto
Switch
Spark in the spark plug
Compression and
fuelling is normal
Fueling normal but poor
compression
No fuel supply
Lack of power or unstable running
Zündfunke ist vorhanden
Compression is normal
and no misfire
Overheating
Others
WARNING:
Fuel must never be poured into the waste water or anywhere
else. This would be punishable facts of the case. In the sewer
010975_304015_betriebs_7k.indd 15 010975_304015_betriebs_7k.indd 15
Cause
1. Wet spark plug electrodes
2. Carbon deposited on the electrodes
3. Insulation failure by insulator damage
4. Improper spark gap
5. Burn out of electrodes
1. Ignition coil inside failure
2. Damaged cable sheath or disconnected
1. Switch is OFF
2. Switch failure
3. Primary wiring earthed
1. Over sucking of fuel
2. Too rich fuel
3. Overflow
4. Clogging of air cleaner
5. Faulty fuel
1. Worn out cylinder, piston or piston ring
2. Gas leakage from cylinder and crank case gasket
1. Choked breather air hole
2. Clogged carburetor
3. Clogged fuel filter
1. Air penetration from fuel pipe joints etc.
2. Air penetration from intake tube joint or carburettor
joint
3. Water in fuel
4. Piston starts to seize
5. Muffler choked with carbon
1. Fuel too lean
2. Clogging of cylinder fin with dust
3. Inferior fuel
4. Carbon deposited in combustion chamber
5. Spark plug electrode red hot
1. Dirty air cleaner
2. Over loading
Reparation
Make them dry
Cleaning
Exchange
Adjust to 0.6-0.7mm
Exchange spark plug
Exchange
Exchange or repair
Set the switch to ON
Exchange
Repair
Drain excess fuel
Adjust carburettor
Adjust or exchange carburettor
Wash with mixed gasoline
Change with proper fuel
Exchange
Apply liquid gasket and reassemble
Cleaning
Cleaning
Exchange fuel filter
Secure connection
Change gasket or tighten screws
Change with proper fuel
Replace piston (and cylinder)
Cleaning
Adjust carburetor
Cleaning
Change with proper fuel
Cleaning
Clean, adjust spark gap (0.6-0.7mm)
Wash with mixed gasoline
Reduce load
there is an extreme risc of explosion by spontaneous ignition
even at low temperature with damage which cannot be
foreseen.
CARSON Gas Devil 304015
GB
15
05.07.2007 14:50:26 Uhr 05.07.2007 14:50:26 Uhr