Commissioning - Titan PKE-HD Notice D'instructions

6.

Commissioning

Connect the PKE-HD manual tool to the compressed air supply by means of the quick-
action coupling mechanism which is supplied. Maximum air pressure (see technical
date).
Important: This tool may only be operated together with compressed air
maintenance unit consisting of a pressure reducer, water separator and
lubricator. It cleans the compressed air, removes condensation and
constantly supplies the motor with the required quantity of oil.
The lubricator is adjusted at the top by means of a screwdriver in such a way that a
drop of oil falls into the sight glass for each strapping. Rotation in a clockwise direction
should result in less oil and in the opposite direction more.
Maximum hose length between the maintenance unit and the strapping tool: 5m.
In no case it is allowed to run the tool without oil being in the
lubricator of the maintenance unit, as this would immediately
destroy the compressed air motor!
No warranty in that case!
The compressed air motor may be driven during the entire operation with filtered and
lubricated compressed air. In terms of quantity approximately 3-5 drops are required
per 1m³ air; this corresponds to 0.12-0.2 g/m³.
Unalloyed mineral oil should be primarily used as lubricating oil. It should have a low
viscosity and be free of resin and acids. A viscosity of 2-4° E at 50° (12-30cSt) has
been proven to be suitable. Permissible motor temperatures are from +5°C to +35°C.
However, for ambient temperatures around +5°C there is a risk of icing.
In this case it is recommended that dry air or corresponding lubricants which are
resistant to icing be used (e.g. "Killfrost Anti-Eis").
Caution! Wear respiratory equipment when antifreeze agents are used.
The following oils may use:
ESSO D 32
D 100
CL 320
DEA Aries 32
Aries 100
The tool may be put into operation after connection to the compressed air supply and the
maintenance unit is adjusted.
PKE-HD
-10° up to +30°
+25° up to +55°
+45° up to +75°
-25° up to +20°
0° up to +50°
H228-HD EU 21/11
MOBIL Almo 525
Almo 527
Almo 528
SHELL Tonna R32
Tonna R100
-20° up to +20°
0° up to +30°
above +15°
-10° up to +30°
+25° up to +55°
26 / 57