Tc 11. Spare Parts - ThermoKey AFS Manuel Technique

ThermoKey Heat Exchange Solutions
TC 10.4 OPERATING PROBLEMS
PROBLEM Water is not reaching the nozzles
SOLUTION Ensure that the inlet valve is fully opened
Ensure that the pressure and flow rate values are correct
PROBLEM The water reaching the nozzles is not sufficient
SOLUTION Ensure that the inlet valve is fully opened
Ensure that the pressure and flow rate values are correct
PROBLEM
Some areas of the finned pack are not being sufficiently covered by the spray jet
SOLUTION
Ensure that the pressure and flow rate values are correct
Check for the presence of foreign bodies inside the nozzles and clean them
Check if nozzles are right oriented in air direction
Excessive accumulation of water inside the remote unit
PROBLEM
SOLUTION Check that the torque of all screws of pipe
Check for the presence of foreign bodies inside the nozzles and clean them
Ensure that the pressure and flow rate values are correct

TC 11. Spare Parts

NOZZLES (U01) - M250502
Axial flow hollow cone+2 gaskets +Baionet collar+2 inox screws
§ §
Materials:Brass material
§ §
RAFUGC
§ §
3,78 l\h @15bar
§ §
NOZZLES (U02) - M250504
Axial flow hollow cone+2 gaskets +Baionet collar+2 inox screws
§ §
Materials:Brass material
§ §
RAFUGC2T
§ §
6,25 l\h @15bar
§ §
NOZZLES (U06) - M250514
Axial flow hollow cone+2 gaskets +Baionet collar+2 inox screws
§ §
Materials:Brass material
§ §
RAFUGC4T
§ §
13,24 l\h @15bar
§ §
19 MT TC R AFS EN 03 2018
NOZZLES (U07) - M250515
Axial flow hollow cone+2 gaskets +Baionet collar+2 inox screws
§ §
Materials:Brass material
§ §
RAFUGC5T
§ §
22,30 l\h @15bar
§ §
MANOMETER - M990601
Manometer D.63 0-40 BAR 1/4"
§ §
MAGNETIC ELECTRO-VALVES (MV4=MV5) - M1906142
Type 1132/04A6 + 9 - 150/R02(HM2) : 1/2" Female Gas Inlets
§ §
220V/230V -50/60HZ-A.C.-IP65
§ §
NC = when the coil is de-energised the plunge stops the refrigerant flow
§ §
INLET 1/2" MAGNETIC ELECTRO-VALVES (MV4=MV5) - M1906386
Type 1132/04S + 9 - 150/R02(HM2): 1/2" Female Gas Inlets
§ §
24V -50/60HZ-A.C.-IP65
§ §
NC = when the coil is de-energised the plunge stops the refrigerant flow
§ §
Magnetic electro-valve
Manometer Magnetic electro-valve
MT TC R AFS EN 03 2018
Technical Manual TC Instruction and technical data
20