GE JGP630 Instructions D'installation page 6

INSTALLATION—GAS CONNECTIONS
PROVIDE ADEQUATE
1
GAS SUPPLY
This cooktop is designed to operate on
natural gas at 4" of water column manifold
pressure and 7" of water column (W.C.)
supply pressure. It is shipped from the
factory set for natural gas. The convertible
pressure regulator supplied with the unit
must be connected in series with the
manifold of the cooktop and must remain in
series with the supply line regardless of
whether natural or L.P. gas is being used.
FOR PROPER OPERATION, THE MAXIMUM
INLET PRESSURE TO THE REGULATOR
MUST BE NO MORE THAN 14" OF WATER
COLUMN PRESSURE. For checking the
regulator, the inlet pressure must be at least
1" W.C.. (or 3.4 KPA) greater than the
regulator output setting. If the regulator is set
for 4" W.C. of water column pressure, the
inlet pressure must be at least 5" W.C. If the
regulator is set for 10" W.C., the inlet pressure
must be at least 11" W.C.. The gas supply line
to the cooktop should be 1/2" or 3/4" pipe.
2 INSTALL REGULATOR
NEVER REUSE OLD CONNECTORS WHEN
INSTALLING THIS COOKTOP.
WARNING:
flexible connectors. The use of old flexible
connectors can cause gas leaks and personal
injury. Always use new flexible connectors
when installing a gas appliance.
Screw a section of pipe
onto the inlet end of the
pressure regulator and
install the coupling.
To reduce the likelihood of gas leaks, apply
teflon tape or a thread compound approved
for use with LP or Natural gases to all
threaded connections.
Installation Instructions
Never reuse old
Pressure
Regulator
Coupling
INSTALL REGULATOR ONTO
3
BURNER BOX BOTTOM
Screw the
regulator onto
the burner box
bottom pipe
connection.
Make sure the
top of the
regulator is
facing towards the
cabinet front,
easily accessible
through the
cabinet doors.
COMPLETE CONNECTION
4
WITH A COUPLING
Complete the
connection
between the
regulator pipe
coupling and
the shut-off valve.
6
Pressure
Regulator
Coupling
Shut-Off
Electrical
Valve
Outlet 12"
Below
Countertop
Pressure
Regulator
Coupling
Shut-Off
Electrical
Valve
Outlet 12"
Below
Countertop