Publicité
Les langues disponibles
Les langues disponibles
INSPECTION AND MAINTENANCE SCHEDULE
It is very important to inspect and maintain your dirt bike regularly. Follow the guidelines in the chart below. The intervals
between periodic services in months are shown. At the end of each interval, be sure to perform and document the mainte-
nance listed.
Any properly trained and qualified person may maintain the emission control device and systems on your Baja unit. Only a
Baja authorized service center may honor your emission control device and systems limited warranty.
WARNING:
Failing to perform recommended maintenance or performing maintenance improperly can lead to an accident and cause
serious personal injury, cause noncompliance to emissions regulations, and may void your warranty. If you are not sure
how to perform the maintenance items below, contact your Baja authorized service center or Baja Motorsports.
Item
Valves*
Spark Plug
Valve Clearance — Inspect, Adjust
Air Filter
Carburetor*
Exhaust System*
Spark Arrestor
Fuel Hose
Engine Lubricant
Brakes
Chain Tension
Wheels
Wheel Bearings
Front and Rear Suspension
Steering System
Steering Shaft Lubrication
(Use Li Grease)*
Bolts, Nuts, Fasteners
* — This item of maintenance should be carried out at a service center. It may also be done by the user with reference to
this manual provided special tools and authorized spare parts are used. The user must also be capable of completing
the procedure.
I = Inspect and clean, adjust, lubricate, or replace as necessary
C = Clean
R = Replace
CAUTION:
If you operate your dirt bike under severe conditions, it will need maintenance more often than shown in the chart above.
Severe conditions include operating under frequent full throttle or in dusty, wet, sandy, or muddy areas. If you have ques-
tions regarding appropriate maintenance intervals for your dirt bike, contact your Baja authorized service center or Baja
Motorsports.
MAINTENANCE
First month
or 20 hours
I
R
I
I
I
I
I
T
A = Adjust
L = Lubricate
13 — English
Initial 3 months
Every 3 months
or 50 hours
C
I Every 20-40 hours (more often in dusty areas)
I
I
I
I
I
T
T = Tighten
Every 6 months
or 50 hours
or 100 hours
C
R
I
I
I
L
T
© 2010 Baja, Inc. All Rights Reserved.
I
I
I
I
I
I
I
I
I
I
Publicité
