Table des Matières
Publicité
Liens rapides
Owner's Instruction and Operation Manual
Model Number:
US2941EB
Report Number: F20-596
Tested to ALT-125, ASTM E2515, ASTM E3053
and CSA B415.1-10 Certified to: UL 1482-11
(R2015) and Certified to: ULC-S627-00-REV1
Use In Mobile Homes (USA Only)
* All Pictures In This Manual Are For Illustrative Purposes Only. Actual Product May Vary.
Save These Instructions In A Safe Place For Future Reference.
SAFETY NOTICE: If this heater is not properly installed, a house fire may result. For
your safety, follow the installation instructions. Never use make-shift compromises
during the installation of this heater. Contact local building or fire officials about
permits, restrictions and installation requirements in your area. NEVER OPERATE
THIS PRODUCT WHILE UNATTENDED.
CAUTION! Please read this entire manual before you install or use your new room
heater. Failure to follow instructions may result in property damage, bodily injury, or
even death. Improper Installation Will Void Your Warranty!
U.S. Environmental Protection Agency
Certified to comply with 2020 particulate
emissions standards.
THIS MANUAL IS SUBJECT TO CHANGE WITHOUT NOTICE.
© 2021 United States Stove Company, 227 Industrial Park Rd., South Pittsburg, TN 37380
R
CALIFORNIA PROPOSITION 65 WARNING:
This product can expose you to chemicals including carbon
monoxide, which is known to the State of California to cause
cancer, birth defects, and/or other reproductive harm. For
more information, go to www.P65warnings.ca.gov
853766D-1002K
Ph. 800-750-2723
Publicité
Table des Matières
Manuels Connexes pour United States Stove US2941EB
Sommaire des Matières pour United States Stove US2941EB
- Page 1 State of California to cause emissions standards. cancer, birth defects, and/or other reproductive harm. For more information, go to www.P65warnings.ca.gov THIS MANUAL IS SUBJECT TO CHANGE WITHOUT NOTICE. © 2021 United States Stove Company, 227 Industrial Park Rd., South Pittsburg, TN 37380 Ph. 800-750-2723...
- Page 2 The instructions pertaining to the installation of your wood stove comply with UL-1482 (R2015) and ULC-S627-00 (R2016) standards. This manual describes the installation and operation of the USSC, US2941EB wood heater. This heater meets the 2020 U.S. Environmental Protection Agency’s cordwood emission limits for wood heaters sold after May 15, 2020.
-
Page 3: Installation Checklist
Declaration of Completion: As the qualified person responsible for the work described above, I confirm that the appliance as associated work has been installed as per manufacturer’s instructions and following any applicable building and installation codes. Signed: ______________________________________ Print Name: __________________________________Date: ______________ Home Owner: RETAIN THIS INFORMATION FOR FUTURE REFERENCE © 2021 United States Stove Company... -
Page 4: Unpack And Inspect
“seats” itself in the door. The tight fit at the factory and hand side of the cabinet door) and pull out on the door. before the heater’s initial firing is to ensure a good seal © 2021 United States Stove Company... - Page 5 When placing the smoke curtain into place ensure the bend it facing toward the fire door Cabinet Door as shown. Fire Door 2. Locate the two hooks inside the firebox above the fire door opening as shown. © 2021 United States Stove Company...
- Page 6 It is very important to position the wood stove as close beneath the heater if the floor is constructed of as possible to the chimney, and in an area that will favor combustible material. If a floor pad is used, it should be © 2021 United States Stove Company...
-
Page 7: Clearances To Combustibles
4. The house is equipped with a well-sealed vapor barrier and tight fitting windows and/or has any powered devices that exhaust house air. 5. There is excessive condensation on windows in the winter. 6. A ventilation system is installed in the house. © 2021 United States Stove Company... - Page 8 Your smoke uncontrollable burn or excessive temperature indicates pipe should be assembled in such a way that the male excessive draft. section (crimped end) of the pipe faces down. Attach © 2021 United States Stove Company...
- Page 9 5. The draft caused by the tendency for hot air to rise will be increased with an interior chimney. © 2021 United States Stove Company...
-
Page 10: Masonry Chimney
1” (26 mm) each, construct a wall and wall combustibles. The clay liner shall run from the pass-through. There shall be a minimum 6” (153 mm) brick masonry outer surface to the inner surface of the © 2021 United States Stove Company... - Page 11 Use this as a pass-through for a minimum roof space, closet or similar concealed space, or a floor, 24-gauge single wall steel chimney connector. Keep or ceiling. solid-pak section concentric with and spaced 1” (26mm) © 2021 United States Stove Company...
- Page 12 If cracks are radiating in all directions from be burned. Any type of well seasoned natural wood the center then the wood should be dry enough to burn. may be used in your stove, but specific varieties have © 2021 United States Stove Company...
-
Page 13: Fueling Instructions
(green). Do not use this wood in your stove. Large CAUTION: amounts of creosote could be deposited in your chimney, creating potential conditions for a chimney DO NOT LEAVE APPLIANCE UNATTENDED THE fire. WITH DOOR OPEN. © 2021 United States Stove Company... -
Page 14: Blower Operation
The blower control knob is located on the side the air too quickly will cause the unit to smoke. of the blower housing. Turn the knob clockwise to turn the blower on. The speed is controlled by turning the © 2021 United States Stove Company... - Page 15 The clean outs are secured to the firebox with two 5/16” screws. Remove the clean outs and vacuum out any accumulated ash. This should be done at least once per month or more frequently if large amounts © 2021 United States Stove Company...
-
Page 16: Chimney Maintenance
OPEN. THIS WOULD RESULT IN OVER FIRING • Always burn dry wood. This allows clean burns and THE STOVE. DAMAGE TO THE STOVE AND EVEN higher chimney temperatures, therefore less creosote HOUSE FIRE MAY RESULT. deposit. © 2021 United States Stove Company... -
Page 17: How To Order Repair Parts
Part numbers and descriptions can be found in the “Repair Parts” section of this manual. Once this information has been gathered you can contact customer service by phone 1-800-750-2723 Ext 5051 or Email parts@usstove.com. Model Information Model Number Serial Number © 2021 United States Stove Company... - Page 18 NOTICE: ANY REPLACEMENT WIRING MUST HAVE EQUIVALENT INSULATION AND TEMPERATURE RATING (105° C). NOTICE: DO NOT ALLOW THE POWER CORD TO TOUCH HOT SURFACES! KEEP THE POWER CORD AT LEAST 12”/30.5 CM FROM THE STOVE OR PIPE SURFACES. © 2021 United States Stove Company...
-
Page 19: Repair Parts
REPAIR PARTS © 2021 United States Stove Company... - Page 20 Call 1-800-750-2723 Ext 5051 or Email to: parts@usstove.com IN ORDER TO MAINTAIN WARRANTY, COMPONENTS MUST BE REPLACED USING USSC PARTS PURCHASED THROUGH YOUR DEALER OR DIRECTLY FROM USSC. USE OF THIRD PARTY COMPONENTS WILL VOID THE WARRANTY. © 2021 United States Stove Company...
- Page 21 Call 1-800-750-2723 Ext 5051 or Email to: parts@usstove.com IN ORDER TO MAINTAIN WARRANTY, COMPONENTS MUST BE REPLACED USING USSC PARTS PURCHASED THROUGH YOUR DEALER OR DIRECTLY FROM USSC. USE OF THIRD PARTY COMPONENTS WILL VOID THE WARRANTY. © 2021 United States Stove Company...
-
Page 22: Service Record
Engineer Name: ____________________________________ Engineer Name: ____________________________________ License No.: ________________________________________ License No.: ________________________________________ Company: __________________________________________ Company: __________________________________________ Telephone No.: _____________________________________ Telephone No.: _____________________________________ Stove Inspected: Chimney Swept: Stove Inspected: Chimney Swept: Items Replaced: ____________________________________ Items Replaced: ____________________________________ © 2021 United States Stove Company...