De-Scaling/Sanitizing Procedure - Koolaire K Serie Manuel D'installation, D'utilisation Et D'entretien

Maintenance

De-scaling/Sanitizing Procedure

Use only approved Ice Machine De-scaler and Sanitizer
for this application (Manitowoc De-scaler part number
94-0546-3 and Manitowoc Sanitizer part number 94-
0565-3). It is a violation of Federal law to use these
solutions in a manner inconsistent with their labeling.
Read and understand all labels printed on bottles before
use.
Do not mix De-scaler and Sanitizer solutions together.
It is a violation of Federal law to use these solutions in a
manner inconsistent with their labeling.
Wear rubber gloves and safety goggles (and/or face
shield) when handling Ice Machine De-scaler or Sanitizer.
Ice machine de-scaler is used to remove lime scale and
mineral deposits. Ice machine sanitizer disinfects and
removes algae and slime.
24
Caution
Caution
Warning
Step 1 Remove the front door to access the evaporator
compartment. Ice must not be on the evaporator during
the clean/sanitize cycle. Set the toggle switch to the OFF
position after ice falls from the evaporator at the end of a
harvest cycle. Or, set the switch to OFF and allow the ice to
melt off the evaporator(s).
Never use anything to force ice from the evaporator.
Damage may result.
Step 2 Remove all ice from the bin/dispenser.
Step 3 Place the toggle switch in the CLEAN position.
Water will flow through the water dump valve and down
the drain. Wait until the water trough refills, then add the
proper amount of ice machine de-scaler.
Model
K0250 K0350 K0420
K0500 K0600 K1000
K1350 K1800
Step 4 Wait until the clean cycle is complete
(approximately 24 minutes). Then disconnect power to the
ice machine (and dispenser when used).
Disconnect the electric power to the ice machine at the
electric service switch box.
Step 5 Remove parts for de-scaling.
Please refer to the proper parts removal for your ice
machine. Continue with step 6 when the parts have
been removed.
Single Evaporator Ice Machines - page 26
Part Number 000012545 Rev 03 07/22
Section 4
Caution
Amount of De-scaler
3 ounces (90 ml)
5 ounces (150 ml)
9 ounces (265 ml)
Warning