Trumpf TruConvert DC 1030 Manuel Opérateur page 95

Number Message
60132 RS-485 communica-
tion alarm.
60142 Battery undervol-
tage.
60145 Wrong polarity on
DC terminal detec-
ted.
60150 Battery voltage over
threshold setting.
60168 Ambient tempera-
ture over allowed
range.
60186 Ambient tempera-
ture under allowed
range.
60192 Fan defective or
stuck.
60200 Precharge condi-
tions could not be
met.
60201 Attached load on
DC link can not be
handled.
60202 DC link could not
be charged
60700 Auxiliary supply
overvoltage.
60703 Auxiliary supply
undervoltage.
Messages d'alarme
Messages d'avertissement
Number Message
10016 Powerfail of 24 V auxiliarysupply has been detected
11000 battery voltage < minimum reference or battery voltage > maximum
reference
Messages d'avertissement
A67-0147-00.BKfr-0
01-01
Effect
No operation pos-
sible.
No operation pos-
sible.
Risk of damaging
hardware.
No operation pos-
sible.
No operation pos-
sible.
No operation pos-
sible.
No operation pos-
sible.
No operation pos-
sible.
No operation pos-
sible.
No operation pos-
sible.
Risk of damaging
hardware.
Unstable system.
2022-06-22
Cause Action
Communication pro- Check RS-485 com-
blem on RS-485 munication.
bus.
Battery voltage too Check battery vol-
low. tage.
Wrong polarity on Check battery pola-
battery detected. rity.
Battery voltage over Change battery
threshold setting. threshold setting.
Ambient tempera- Check the ambient
ture over allowed temperature.
range.
Ambient tempera- Check the ambient
ture under allowed temperature.
range.
Fan is defective or Check fan.
stuck.
Precharge condi- Check droop-mode
tions could not be settings, DC link
met. and battery voltage.
Attached load on Reduce DC link
DC link can not be load or change pre-
handled. charge procedure.
DC link could not Check DC link and
be charged connected compo-
nents.
Auxiliary supply vol- Check the external
tage too high. 24-V auxiliary sup-
ply.
Auxiliary supply vol- Check the external
tage too low. 24-V auxiliary sup-
ply.
Recherche des erreurs
Detec-
ted by
DC-DC
module
DC-DC
module
DC-DC
module
DC-DC
module
DC-DC
module
DC-DC
module
DC-DC
module
DC-DC
module
DC-DC
module
DC-DC
module
DC-DC
module
DC-DC
module
Tab. 29
Caused by
System control
DC-DC module
Tab. 30
89