Remote Condenser/Line Set Installation; Remote Ice Machine Refrigerant Charge - Koolaire K0250 Serie Manuel D'installation Et D'entretien

Section 2

Remote Condenser/Line Set Installation

Remote Single
Ice Machine
Circuit Condenser
K1000
K1350
K1800
*Line Set Discharge Line
RTK 1/2" (1.27 cm)
RLK 1/2" (1.27 cm)
Air Temperature Around the Condenser
Minimum
-20°F (-29°C)
Important
Remote systems are only approved and warranted as a
complete new package. Warranty on the refrigeration
system will be void if a new ice machine head section is
connected to pre-existing (used) tubing or remote
condensers.
Part Number 000012545 Rev01 9/15
Line Set*
RTK-20-R410A
KC1000 RTK-35-R410A
RTK-50-R410A
RLK-20-R410A
KC1350 RLK-35-R410A
RLK-50-R410A
RLK-20-R410A
KC1350 RLK-35-R410A
RLK-50-R410A
Liquid Line
5/16" (.79 cm)
3/8" (.95 cm)
Maximum
120°F (49°C)

REMOTE ICE MACHINE REFRIGERANT CHARGE

Each remote ice machine ships from the factory with a
refrigerant charge appropriate for installation with line sets
of up to 50' (15 m). The serial tag on the ice machine
indicates the refrigerant charge.
Additional refrigerant may be required for installations
using line sets between 50' and 100' (15-30 m) long. If
additional refrigerant is required, refer to the chart below for
the correct amount to be added.
Ice Machine
K1000
K1350
K1800
Important
EPA CERTIFIED TECHNICIANS
If remote line set length is between 50' and 100' (15 and
30 m), add additional refrigerant to the nameplate
charge. Refer to the table below for the model being
worked on.
Tubing length: ______________________________________
Refrigerant added to nameplate: _______________________
New total refrigerant charge: __________________________
!
Potential Personal Injury Situation
The ice machine
Installation of the line sets must be performed by a
properly trained and EPA certified refrigeration
technician aware of the dangers of dealing with
refrigerant charged equipment.
Installation Instructions
Refrigerant to be added for
50'-100' Line Sets
2 lbs (907g)
2 lbs (907g)
2 lbs (907g)
Warning
contains refrigerant charge.
11