Important Notice - Qlima S5025 Manuel D'installation

IMPORTANT NOTICE:

Install this device only when it complies with local/national legislation, ordinances and standards. This pro-
duct is intended to be used as an air conditioner in residential houses and is only suitable for use in dry
locations, in normal household conditions, indoors in living room, kitchen and garage. Check the mains
voltage and frequency. This unit is only suitable for earthed sockets, connection voltage 220-240 V~ / 50 Hz.
Model SC41xx & SC5xxx has to be connected directly to the supply source.
This installation manual is intended for use by individuals possessing adequate backgrounds of electrical,
electronic, refrigerant and mechanical experience. Any attempt to install or repair the appliance may result
in personal injury and property damage. The manufacturer or seller cannot be responsible for the interpre-
tation of this information, nor can it assume any liability in connection with its use.
The information, specifications and parameter are subject to change due to technical modifications or
improvement without any prior notice. The accurate specifications are presented on the nameplate label.
• Please read this installation manual completely before installing the product.
• W hen the power cord is damaged, replacement work shall be performed by authorized personnel only.
• Installation work must be performed in accordance with all European, national and / or local directives
and standards and must be done by authorized personnel only. The guarantee is invalid for damage
caused by neglect or by actions that deviate from those in this instruction booklet.
• Always make sure to wear the correct personal safety protections such as protective eyewear, gloves,
mouthcaps, ear protection etc.
Internet:
For your convenience you can download the latest version of the user-, installation- and/or service manual
on www.qlima.com
G
WARNING!
Do not install, remove and/or reinstall the unit by yourself if you do not have the adequate
electrical, electronic, refrigerant, mechanical experience and authorisation.
• Improper installation can cause water leakage, electrical shock, refrigerant leakage or fire.
Please consult authorized dealer or specialized air conditioner engineer for the installation
work. Please note faults caused by improper installation is not covered by warranty.
• Unit must be installed in an easily accessible area. Any additional cost required to hire special
equipment to service the unit will be the responsibility of the customer
4
42 42
CONTENT
1. Safety precautions
2. Items packed with the unit
2.1 items packed with the unit (for SC41xx & SC5xxx models)
2.2 items packed with the unit (for S41xx & S5xxx models)
3. Activities for installing the air conditioner for the SC41xx & SC5xxx models.
4. Activities for installing the air conditioner for the S41xx & S5xxx models.
5. Determining the location of the inside and outside unit.
5.1 D etermining the location of the inside and outside unit for the S41xx,
S5xxx, SC41xx & SC5xxx models.
5.2 D etermining the location of the exterior unit for the S41xx, S5xxx, SC41xx
& SC5xxx models.
6. Possibilities for installing the piping from the interior unit to The exterior unit.
7. Mounting the installation plate and making the piping feedthrough.
7.1 Mounting the installation plate of the interior unit.
7.2 Drilling the piping, condensation hose and cable feed-through.
8. Connection the coolant pipes.
8.1 Connecting and disconnecting the coolant pipes for the SC41xx & SC5Xxx
models.
8.2 Connecting the coolant pipes for the S41xx & S5xxx models.
9. C onnection the condensation drainage hose for the S41xx, S5xxx, SC41xx &
SC5xxx models.
9.1 Connection the condensation drainage hose to the interior unit.
9.2 Drain joint installation.
10. Electrical work.
11. Connecting the electrical cables.
11.1 Connecting the electrical cables for the SC41xx & SC5xxx models.
11.2 Connecting the electrical cables for the S41xx & S5xxx models.
12. Evacuating the cooling system of the S41xx & S5xxx models.
13. Checking the cooling system for leakage on the S41xx, S5xxx, SC41xx &
SC5xxx models.
14. Topping up coolant for piping lengths above 05 metres.
15. Test running after installation.
4
43 43