Important Safety Instructions; Safety Alert Symbol; Heater Characteristics / Specifications - BriskHeat Custom Serie Manuel D'instructions

IMPORTANT SAFETY INSTRUCTIONS

SAFETY ALERT SYMBOL

The symbol above is used to call your attention to instructions
concerning your personal safety. It points out important safety
precautions. It means "ATTENTION! Become Alert! Your
Personal Safety is involved!" Read the message that follows
and be alert to the possibility of personal injury or death.
DANGER
A person who has not read and understood all operating
Instructions is not qualified to operate this product.
DANGER
•
Do not immerse heater in liquid.
•
Keep volatile or combustible material away from heater
when in use.
•
Use heater only in approved locations.
•
Keep sharp metal objects away from heater.
•
All DHCX and DHNX heaters have T ratings described
in Article 501 of the NEC code. The heaters should not
be used in an area with a lower T rating than the
heater.
•
Do not modify this product. Modification will void
warranty.
Failure to observe these warnings may result in electric shock,
risk of fire, and personal injury.
WARNING
End-User Must Comply to the Following:
•
Only qualified personnel are allowed to connect
electrical wiring.
•
Disconnect all supply power at the source before
making any power connections.
•
All electrical wiring must follow local electrical codes.
•
The person who performs the final installation / wiring
must be qualified for this work.
•
The end-user is responsible for providing a suitable
disconnecting device.
•
The end-user is responsible for providing suitable
electrical protection device. It is highly recommended
that a ground fault circuit breaker is used.
•
DHCX and DHNX series: A NRTL (National
Recognized Testing Laboratory) listed temperature
controller must be used to control the surface
temperature of the heaters. The controller must be
approved for the area where it is located.
•
DHCX and DHNX series: Heaters provide surface
heating, Consult proper authorities for information for
safe heating of materials/contents of any vessel
heated by DHCX and DHNX heaters.
Failure to observe these warnings may result in personal injury
or damage to the heater.
®
© BriskHeat Corporation. All rights reserved.
Silicone Rubber Drum and Pail Heaters
DANGER
Immediate hazards which WILL result in severe personal injury or
death.
WARNING
Hazards or unsafe practices that COULD result in severe personal
injury or death.
CAUTION
Hazards or unsafe practices that COULD result in minor personal
injury or property damage.
CAUTION
•
Never handle the heater while it is in operation; Always
disconnect the heater from the power source and allow
to cool prior to handling.
•
Inspect heater before use (see page 10).
•
Never operate a heater without a temperature control
device.
•
Do not wrap the heater over itself.
•
If spillage of foreign matter onto heater occurs,
disconnect from power source and clean after heater is
allowed to cool.
•
Never operate a heater without an appropriate heat
sink (device being heated is considered a heat sink).
•
Do not operate heater above rated temperature value.
•
Fasten heater to device using approved methods only.
•
Do not repair damaged or faulty heaters.
•
Do not crush or apply severe physical stress on heater
or cord assembly.
•
Disconnect heater when not in use.
•
Use specified sized heater with same sized drum. Do
not use for other applications.
•
DHCX series: Never allow the full weight of the thermal
bulb controller to hang from the heater.
•
DHNX series: The metal enclosure must not support
more than 10lbs (4.5kg).
Failure to observe these warnings may result in personal injury
or damage to the heater.
3

HEATER CHARACTERISTICS / SPECIFICATIONS

Part Series DHCH DHCS DHLS DHCX DHNH
Band Width 4" 4" 4" 8" 4"
Layers of
3 2 2 4 3
Silicone
Max Power
Density 4.5 4.5 4.5 2.5 4.5
(W/in²)
Min Exposure -60°F -60°F -60°F -60°F -60°F
Temperature (-51°C) (-51°C) (-51°C) (-51°C) (-51°C)
Max Exposure 450°F 450°F 450°F 400°F 450°F
Temperature (232°C) (232°C) (232°C) (204°C) (232°C)
Max Humidity 95% 95% 95% 95% 95%
Ingress
IP54 IP54 IP54 IP56 IP56
Protection
Grounded
Heating ✓ ✓ ✓ ✓ ✓
Element
Moisture and
Chemical ✓ ✓ ✓ ✓ ✓
Resistant
Suitable for
✓ ✓ ✓ ✓ ✓
Metal
Container
Suitable for
Plastic
Container
Suitable for
✓
Hazardous
Locations*
Adjustable
✓ ✓ ✓ ✓
Thermostat
Controller
Built-in High
✓
Limit Safety
Thermostat
* Refer to product label for approved hazardous locations
®
© BriskHeat Corporation. All rights reserved.
Silicone Rubber Drum and Pail Heaters
DHNS DHNX DPCH DPCS DPNS DPNH ECONO
4" 8" 4" 4" 4" 4"
2 4 3 2 2 3
4.5 2.5 1.2 1.2 1.2 1.2
-60°F -60°F -60°F -60°F -60°F -60°F -60°F
(-51°C) (-51°C) (-51°C) (-51°C) (-51°C) (-51°C) (-51°C)
450°F 400°F 450°F 450°F 450°F 450°F 450°F
(232°C) (204°C) (232°C) (232°C) (232°C) (232°C) (232°C)
95% 95% 95% 95% 95% 95%
IP56 IP56 IP54 IP54 IP56 IP56 IP54
✓ ✓ ✓ ✓ ✓ ✓
✓ ✓ ✓ ✓ ✓ ✓
✓ ✓ ✓ ✓ ✓ ✓
✓ ✓ ✓
✓
✓ ✓
✓
4
3.6"
2
4.5
95%
✓
✓
✓
✓