Important Safety Instructions; Safety Alert Symbol; Specifications - BriskHeat GBH0250-1 Manuel D'instructions

IMPORTANT SAFETY INSTRUCTIONS

SAFETY ALERT SYMBOL

The symbol above is used to call your attention to
instructions concerning your personal safety. It points out
important safety precautions. It means "ATTENTION!
Become Alert! Your Personal Safety is involved!" Read
the message that follows and be alert to the possibility of
personal injury or death.
DANGER
A person who has not read and understood all operating
Instructions is not qualified to operate this product.
DANGER

Do not immerse heater in liquid.

Keep volatile or combustible material away from
heater when in use.

Use heater only in approved locations.

Keep sharp metal objects away from heater.
Failure to observe these warnings may result in electric
shock, risk of fire, and personal injury.
WARNING
End-User Must Comply to the Following:

Only qualified personnel are allowed to connect
electrical wiring.

Disconnect all supply power at the source before
making any power connections.

All electrical wiring must follow local electrical
codes and highly recommend following NEC
Article 427.

The person who performs the final installation /
wiring must be qualified for this work.

The end-user is responsible for providing a
suitable disconnecting device.

The end-user is responsible for providing suitable
electrical protection device. It is highly
recommended that a ground fault circuit breaker
be used.
Failure to observe these warnings may result in personal
injury or damage to the heater.
®
© BriskHeat Corporation. All rights reserved.
Silicone Rubber Beaker Heater
DANGER
Immediate hazards which WILL result in severe personal
injury or death.
WARNING
Hazards or unsafe practices that COULD result in severe
personal injury or death.
CAUTION
Hazards or unsafe practices that COULD result in minor
personal injury or property damage.
CAUTION

Never handle the heater while it is in operation;
always disconnect the heater from the power
source and allow to cool prior to handling.

Inspect heater before use.

Never operate heater without a temperature
control device.

Do not wrap the heater over itself. Only hook and
loop closure mating surfaces are intended to
overlap.

If spillage of foreign matter onto heater occurs,
disconnect from power source and clean after
heater is allowed to cool.

Never operate a heater without an appropriate
heat sink (device being heated is considered a
heat sink).

Do not operate heater above rated temperature
value.

Fasten heater to device using approved methods
only.

Do not repair damaged or faulty heaters.

Do not crush or apply severe physical stress on
heater or cord assembly.

Disconnect heater when not in use.
Failure to observe these warnings may result in personal
injury or damage to the heater.
3

SPECIFICATIONS


Maximum exposure temperature:
450 °F (232 °C )

120, 230, or 240 VAC

2 2
Power density: 0.8 W/cm (5.0 W/in )

Heating element is laminated between
two layers of 15mil fiberglass reinforced
silicone rubber

1 in (25 mm) wide hook and loop fastener

Moisture, chemical, and radiation resistant

Dielectric strength of over 2000 volts

24 in (610 mm) long power leads with

120 VAC: Standard 2-prong NEMA 1-15 plug

230 VAC: Crimped Ferrule Wire Connection

240 VAC GBHE: Crimped Ferrule Wire with Grounded Wire Connection

GBH Series:
Heater Heater
Size Diameter
Height Width
ml in (mm)
in (mm) In (mm)
250 2.7 (69) 3.0 (76) 12.25 (311)
400 3.0 (76) 3.5 (89) 13.75 (349)
600 3.6 (91) 4.0 (102) 15.00 (381)
1000 4.3 (109) 4.6 (117) 17.25 (438)
GBHE Series:
Heater Heater
Size Diameter
Height Width
ml in (mm)
in (mm) In (mm)
250 2.7 (69) 3.25 (83) 12.25 (311)
400 3.0 (76) 3.5 (89) 13.75 (349)
600 3.6 (91) 4.0 (102) 15.00 (381)
1000 4.3 (109) 4.6 (117) 17.25 (438)
®
© BriskHeat Corporation. All rights reserved.
Silicone Rubber Beaker Heater
Total Part Number Part Number
Watts 120 VAC 230 VAC
150 GBH0250-1 GBH0250-2
200 GBH0400-1 GBH0400-2
250 GBH0600-1 GBH0600-2
350 GBH1000-1 GBH1000-2
Total Part Number Part Number
Watts 120 VAC 240VAC
N/A
150 GBHE0250-2
N/A
200 GBHE0400-2
N/A
250 GBHE0600-2
N/a
350 GBHE1000-2
4