Table des Matières
Publicité
Liens rapides
C24EO SERIES
STEAMER
MODEL
ML
C24EO3
ML-136006
C24EO5
ML-136007
For additional information on Vulcan-Hart or to locate an authorized parts
and service provider in your area, visit our website at www.vulcanequipment.com
VULCAN-HART
DIVISION OF ITW FOOD EQUIPMENT GROUP, LLC
WWW.VULCANEQUIPMENT.COM
INSTALLATION &
OPERATION MANUAL
3600 NORTH POINT BLVD.
BALTIMORE, MD 21222
FORM F-37496 (03-14 )
Publicité
Table des Matières
Sommaire des Matières pour Vulcan C24EO Serie
- Page 1 MODEL C24EO3 ML-136006 C24EO5 ML-136007 For additional information on Vulcan-Hart or to locate an authorized parts and service provider in your area, visit our website at www.vulcanequipment.com VULCAN-HART 3600 NORTH POINT BLVD. DIVISION OF ITW FOOD EQUIPMENT GROUP, LLC BALTIMORE, MD 21222 WWW.VULCANEQUIPMENT.COM...
- Page 2 SERVICE OR MAINTENANCE CAN CAUSE PROPERTY DAMAGE, INJURY OR DEATH. READ THE INSTALLATION, OPERATING AND MAINTENANCE INSTRUCTIONS THOROUGHLY BEFORE INSTALLING OR SERVICING THIS EQUIPMENT. IN THE EVENT OF A POWER FAILURE, DO NOT ATTEMPT TO OPERATE THIS DEVICE. — 2 — © VULCAN-HART, 2014...
-
Page 3: Table Des Matières
C24EO SERIES STEAMER TABLE OF CONTENTS INSTALLATION, OPERATION AND CARE OF MODEL C24EO SERIES STEAMERS ....5 GENERAL ............................5 INSTALLATION ..........................5 UNPACKING..........................5 INSTALLATION CODES AND STANDARDS ................5 LOCATION...........................5 LEVELING FEET .........................6 LEVELING ...........................6 ANCHORING STEAMER ......................6 STACKING STAND ........................6 ELECTRICAL CONNECTIONS ....................7 ELECTRICAL DATA ........................8 SERVICE CONNECTIONS ......................8 Water Connections ........................8... - Page 4 C24EO SERIES STEAMER COOKING GUIDELINES ......................18 Preparation ..........................18 Frozen Food Items .......................18 PRODUCTS TO BE COOKED IN SOLID PANS ...............19 PRODUCTS TO BE COOKED IN PERFORATED PANS ............20 TROUBLESHOOTING ........................22 SERVICE AND PARTS INFORMATION ..................23 — 4 —...
-
Page 5: Installation, Operation And Care Of Model C24Eo Series Steamers
If the supply and equipment requirements do not agree, do not proceed with 1. Local codes. the installation. Contact your dealer or Vulcan- 2. Canadian Electric Code, CSA C22.2 (latest Hart immediately. edition). Copies may be obtained from... -
Page 6: Leveling Feet
C24EO SERIES STEAMER LEVELING FEET ANCHORING STEAMER This steamer is shipped with four 2" leveling 1. Place steamer in the desired location on feet. Optional 4" leveling feet are available. the countertop and mark four corners. The 2" feet can be removed and the optional 4" Remove the steamer and drill "... -
Page 7: Electrical Connections
C24EO SERIES STEAMER ELECTRICAL CONNECTIONS To Control Transformer S , 3 0 : Electrical and S , 1 grounding connections must comply with the applicable portions of the National Electrical Code and/or other local electrical codes. When making electrical connections, use copper rimary taps of Control Transformer must be connected wire suitable for at least 200°F (90°C). -
Page 8: Electrical Data
C24EO SERIES STEAMER equipment life. Water conditions vary from one ELECTRICAL DATA location to another. Ask your municipal water supplier for details about your local water supply Model Volts KW Amp @ Amp @ prior to installation. Presence of sediment, silica, 3 PH excess chlorides or other dissolved solids may C24EO3... -
Page 9: Vent Hood
C24EO SERIES STEAMER 4. Install the " NPT close nipple (1 " long) INSTALLATION STARTUP PROCEDURE into drain. 5. Install " NPT 90° elbow onto pipe nipple. : The steamer and its parts are hot. Use care when operating, 6. Re-use hose barb. cleaning or servicing the steamer. -
Page 10: Calibration Procedure
C24EO SERIES STEAMER 5. Close the compartment door and wait ELEVATION (FT) DIGITAL THER- approximately 10 minutes for unit to preheat. MOMETER - °F (C) 6. Rotate the Timer to 5 minutes. The Timer Sea Level 210 (99) will not start counting down until the cavity 1,000 208 (98) has reached preheat temperature. - Page 11 NOTE: If unit cannot be calibrated call your Authorized Vulcan Servicer. NOTE: Temperature display on control is for 7. If correct temperature reading is not attained reference only. When calibrating, use after 3 attempts, call your Authorized Vulcan the recorded temperature from meter. Servicer. — 11 —...
-
Page 12: Operation
C24EO SERIES STEAMER OPERATION CONTROLS OPERATING THE STEAMER 1. Push the the drain lever in to close the drain : The steamer and its valve. parts are hot. Use care when operating, 2. Open the door and pour water into the cleaning or servicing the steamer. -
Page 13: Shutdown
C24EO SERIES STEAMER SHUTDOWN EXTENDED SHUTDOWN 1. Rotate Timer to OFF position. 1. Fully depress Power Switch to OFF position. 2. Fully depress Power Switch to OFF 2. Clean the interior and exterior of unit. position. 3. Leave door open. 3. -
Page 14: Cleaning
C24EO SERIES STEAMER CLEANING Thoroughly clean the exposed surfaces (sides, COOKING COMPARTMENT DRAIN front, door and top) with a damp cloth and polish Remove any particles or debris that may be with a clean cloth daily. To remove discolorations, blocking the drain. Make a solution of warm use a nonabrasive cleaner. -
Page 15: Stainless Steel Equipment Care And Cleaning
C24EO SERIES STEAMER Water comes out of the faucet in varying degrees STAINLESS STEEL EQUIPMENT CARE of hardness. Depending on what part of the AND CLEANING country you live in, you may have hard or soft Contrary to popular belief, stainless steels water. - Page 16 C24EO SERIES STEAMER 4. Treat your water. 7. Never use hydrochloric acid (muriatic acid) on stainless steel. Though this is not always practical, softening hard water can do much to reduce 8. Regularly restore/passivate stainless deposits. There are certain fi lters that can be steel.
-
Page 17: Maintenance
If the door gasket is leaking due to a nick or Part Number 854893-13 (qty. 1). cut, it must be replaced. Damage to the gasket • Contact the local Authorized Vulcan sealing surface will cause steam leakage. Servicer or refer to website www. vulcanequipment.com... -
Page 18: Cooking Hints
C24EO SERIES STEAMER COOKING HINTS The steamer effi ciently cooks vegetables and PREPARATION other foods for immediate serving. Steam Prepare vegetables, fruits, meats, seafood and cooking should be carefully time controlled. poultry normally by cleaning, separating, cutting, Keep hot food holding-time to a minimum to removing stems, etc. -
Page 19: Products To Be Cooked In Solid Pans
C24EO SERIES STEAMER PRODUCTS TO BE COOKED IN SOLID PANS PRODUCT TIME (MINUTES) WEIGHT PER PAN Eggs, Scrambled 9 to 12 8 doz. Rice, Long Grain (Cover with 4 cups water/lb.) 23 to 25 2 lbs. Pasta (Place perforated pan inside solid pan, cover with cold water) Spaghetti –... -
Page 20: Products To Be Cooked In Perforated Pans
C24EO SERIES STEAMER PRODUCTS TO BE COOKED IN PERFORATED PANS PRODUCT TIME (MINUTES) WEIGHT PER PAN SEAFOOD Clams Frozen 9 to 12 3 doz. Fresh, Cherrystone 4 to 6 3 doz. King Crab, Frozen Claws 3 to 4 lbs. Legs 3 to 6 lbs. - Page 21 C24EO SERIES STEAMER PRODUCT TIME (MINUTES) WEIGHT PER PAN VEGETABLES (Cont’d.) Broccoli Spears, Frozen 6 to 8 4 lbs. Spears, Fresh 4 to 6 5 lbs. Flowerettes, Frozen 4 to 6 5 lbs. Cabbage, Fresh, 1/6 Cut 6 to 8 5 lbs.
-
Page 22: Troubleshooting
REMOVAL OF LIME SCALE DEPOSITS). Not connected to correct If voltage is not correct, voltage. contact your Authorized Vulcan Servicer. Door leaks Damaged door gasket. Check door gasket for damage. Damage to gasket sealing If adjustment is needed, surface. -
Page 23: Service And Parts Information
C24EO SERIES STEAMER SERVICE AND PARTS INFORMATION To obtain service and parts information concerning this model, contact the Authorized Vulcan Servicer in your area. Refer to our website, www.vulcanequipment.com for a complete listing of Authorized Service and Parts depots. When calling for service, the following information (located on your machine data plate) must be available:... - Page 24 C24EO SERIES STEAMER (03-14) — 24 — PRINTED IN U.S.A.