Poulan PD4016 Manuel D'instructions page 14

STORAGE
WARNING! Stop the engine and allow it to cool.
Secure the unit before storing or transporting it
in a vehicle. Store the unit and fuel in an area
where fuel vapors cannot reach sparks or open
flames from water heaters, electric motors,
switches, furnaces, etc.
WARNING ! Store the unit with all guards in
place. Position so that any sharp object cannot
accidentally cause injury to passersby. Store
the unit out of reach of children.
Before storing, drain all fuel from the unit. Start the engine
·
and allow it to run until it runs completely out of fuel.
WARNING! Always stop the unit and disconnect the spark plug before performing all of the recommended
remedies below except remedies that require operation of the unit.
TROUBLE: Engine will not start or will run only a few seconds after starting.
CAUSE
1. Ignition switch off.
2. Engine flooded.
3. Fuel tank empty.
4. Spark plug not firing.
5. Fuel not reaching carburetor.
TROUBLE: Engine will not idle properly.
CAUSE
1. Idle speed r e q u i r e s adjustment.
2. Carburetor requires adjustment.
TROUBLE: Engine will not accelerate, lacks power, or dies under a load.
CAUSE
1. Air filter dirty.
2. Spark plug fouled.
3. Chain brake locked.
4. Carburetor requires adjustment.
TROUBLE: Engine smokes excessively.
CAUSE
1. Too much oil mixed with gasoline.
TROUBLE: Chain moves at idle speed.
CAUSE
1. Idle speed r e q u i r e s adjustment.
2. Clutch requires repair.
Clean the unit before storing. Pay particular attention to the
·
air intake area, keeping it free of debris. Use a mild
detergent and sponge to clean the plastic surfaces.
Ensure the machine is cleaned and that a complete service
·
is carried out before long-term storage.
The guide bar and chain should be covered with a
·
scabbard when the machine is being transported or in
storage in order to prevent accidental contact with the
sharp chain. Even a non-moving chain can cause serious
cuts to yourself or others that make contact with an
exposed chain.
CAUTION: It is important to prevent gum deposits from
forming in essential fuel system parts such as the
carburetor, fuel filter, fuel hose, or fuel tank during
storage. Alcohol blended fuels (called gasohol) or using
ethanol or methanol can attract moisture which leads to
fuel mixture separation and formation of acids during
storage. Acidic gas can damage the engine.
TROUBLESHOOTING
REMEDY
See "STARTING" in the STARTING AND STOPPING
·
section.
See "Starting a Flooded Engine" in the OPERATION
·
section.
Fill tank with correct fuel mixture. See "FUELING THE
·
ENGINE" in the STARTING AND STOPPING section.
Install new spark plug. See "SPARK PLUG" in the
·
MAINTENANCE section.
Check for dirty fuel filter; replace.
·
Check for kinked or split fuel line; repair or replace.
·
REMEDY
See "CARBURETOR ADJUSTMENT" in the
·
MAINTENANCE Section.
Contact an authorized service dealer.
·
REMEDY
Clean or replace air filter.
·
Clean or replace plug and regap.
·
Unlock chain brake. See "STARTING POSITION" in the
·
STARTING AND STOPPING section.
Contact an authorized service dealer.
·
REMEDY
Empty fuel tank and refill with correct fuel mixture.
·
REMEDY
See "CARBURETOR ADJUSTMENT" in the
·
MAINTENANCE Section.
Contact an authorized service dealer.
·
14