Lubrication - Ingersoll Rand PL-MANW Mode D'emploi

Initial Start-up.
Each Compressor Unit built is extensively tested at the
factory before shipment.
Check the oil level and for any oil leaks on a daily
basis. This must be done when the Unit is off. Top up
the Oil level on a monthly basis.
Use only Ingersoll-Rand All Season Select Oil. Also, do
not mix the Ingersoll-Rand oil with any other lubricant.
Oil Changes.
Drain the existing oil from the Unit. Running the Unit
prior to draining the oil will ensure that the oil will drain
relatively quickly.
Fill the Oil Reservoir to the bottom thread at the Oil
Filler Plug. Do not under or overfill. See drawing below.
Oil Filler Plug
O Ring
Section Through Crankcase
At Oil Fill Port
Compressor Lubricant
All Season Select is a synthetic fluid specifically formulated to protect and preserve you Ingersoll Rand small
reciprocating air compressor through a broad range of temperature as well as better start-up in colder climate
conditions. With its outstanding formulation, All Season Select enables you to run 2000 hours of service between
changeouts under normal operating conditions.
PART NO.
32318875
32318883

Lubrication

Proper Oil Level
(to bottom thread of Oil Fill Port)
DESCRIPTION
Lubricant, All Season Select - QUART
Lubricant, All Season Select - CASE OF 12 QUARTS
Do not attempt to operate the Unit without first
checking whether there is oil in the Pump
Crankcase. Add oil as required. Serious
damage may result from use, however limited,
without oil.
Use of improper oil may negatively affect
Compressor performance or shorten Unit life.
Resulting problems are not covered by the
Ingersoll-Rand Warranty.
Condensation (water) may form in the Pump if
the Compressor has limited use or is installed
in a very humid environment. As the water will
tend to settle on the bottom of the Reservoir,
drain the water from the Reservoir until you
notice oil draining. Top up with new oil. Also,
change the oil more often than indicated on the
Maintenance Schedule.
- 6 -
PL-MANW
Rev.B, Nov'20