Witter R40A Notice De Montage

MATERIALS
A 1 Cross Bar with European facing to 94/20/EC A50-1
B 1 Bracket
C 1 Side Bracket
D 2 M10 x 40 x 1.5mm pitch Bolts, Nuts, Lock Washers and Flat Washers. (GRADE 10.9)
E 1 M10 x 40 x 1.5mm pitch Bolts and Lock Washers. (GRADE 10.9)
F 2 M14 x 100 x 2.0mm pitch Bolts, Lock Washers and Flat Washers
G 1 M12 x 35 x 1.75mm pitch Bolts, Nuts, and Lock Washers.
H 1 M14 x 40 x 2.0mm pitch Bolts and Lock Washers.
CB 2 M16 x 50mm Coupling Bolts, Nuts, Lock Washers
Z 1 ZEP35 Electrical plate (not shown)
FITTING
1. Remove the left hand bumper reflector by unclipping from inside the bumper and drill two holes as shown below.
2. Remove two existing M8 nuts (with captive washers) from studs located in the rear panel either side of the nearside
chassis rail, using the drilled bumper holes for access.
3. Loosely assemble Side Bracket (C) to nearside chassis rail using fasteners (F).
4. Assemble Cross Bar (A) to Side Bracket (C) and to the three holes in the vehicle towing loop bracket using fasteners (D),
(E), (G) and (H).
5. Fully tighten all fasteners except the rearmost fastener (F)
6. Remove the rearmost fastener (F) and assemble Bracket (B) over the M8 studs located in the rear panel. Secure to
vehicle and Bracket (C) using fasteners (F) and existing M8 nuts (with captive washers) (X) and fully tighten.
7. Refit bumper reflector.
Note: This towbar must be used with either a Witter Towball (part number Z11) or Class A50-1 or A50-X towball dimensionally
Conforming to A50-1 with a 'D' and 'S' value greater than or equal to that of the towbar.
Please refer to the vehicle specification for the trailer weight and nose limits, which must be observed.
Recommended torque settings: M8 - 27Nm, M10 - 53 Nm, M12 - 95 Nm, M14 - 150 Nm, M16 - 214 Nm
Grade 10.9: M12 – 139Nm, M10 – 78Nm
G
H
x
x
B
F
C B
Fitting
Instructions
F
C B
µW0001R40A-FIT$010802220000DÄ
W0001R40A-FIT$010802220000
For Landrover Freelander 2
EC Type Approval No: e11*94/20*6809*00
D-Value 10.91kN; S-Value 150kg
C
A
TOWBAR
R40A
2006-
D R IL L O U T
H A T C H E D A R E A S
1 2 0
L H S B U M P E R R E F L E C T O R
R E C E S S
D
E
D