Publicité
Liens rapides
Owner's Instruction and Operation Manual
Model Number:
US1800E
Report Number: F19-552
Tested Per EPA Methods ALT-125, ASTM E2515,
ASTM E3053 and CSA B415
Certified to: UL 1482-2011 (R2015), ULC-628-93
Do not install this heater in a mobile home or trailer.
* All Pictures In This Manual Are For Illustrative Purposes Only. Actual Product May Vary.
Save These Instructions In A Safe Place For Future Reference.
SAFETY NOTICE: If this heater is not properly installed, a house fire may result. For
your safety, follow the installation instructions. Never use make-shift compromises
during the installation of this heater. Contact local building or fire officials about
permits, restrictions and installation requirements in your area. NEVER OPERATE
THIS PRODUCT WHILE UNATTENDED.
CAUTION! Please read this entire manual before you install or use your new room
heater. Failure to follow instructions may result in property damage, bodily injury, or
even death. Improper Installation Will Void Your Warranty!
U.S. Environmental Protection Agency
Certified to comply with 2020 particulate
emissions standards.
THIS MANUAL IS SUBJECT TO CHANGE WITHOUT NOTICE.
© 2021 United States Stove Company, 227 Industrial Park Rd., South Pittsburg, TN 37380
All manuals and user guides at all-guides.com
R
CALIFORNIA PROPOSITION 65 WARNING:
This product can expose you to chemicals including carbon
monoxide, which is known to the State of California to cause
cancer, birth defects, and/or other reproductive harm. For
more information, go to www.P65warnings.ca.gov
853650D-1805K
Ph. 800-750-2723
Publicité
Manuels Connexes pour United States Stove Company US1800E
Sommaire des Matières pour United States Stove Company US1800E
- Page 1 State of California to cause emissions standards. cancer, birth defects, and/or other reproductive harm. For more information, go to www.P65warnings.ca.gov THIS MANUAL IS SUBJECT TO CHANGE WITHOUT NOTICE. © 2021 United States Stove Company, 227 Industrial Park Rd., South Pittsburg, TN 37380 Ph. 800-750-2723...
- Page 2 The instructions pertaining to the installation of your wood stove comply with UL 1482-2011 (R2015) and ULC-628- 93 standards. This manual describes the installation and operation of the USSC, US1800E wood heater. This heater meets the 2020 U.S. Environmental Protection Agency’s crib wood emission limits for wood heaters sold after May 15, 2020.
- Page 3 Declaration of Completion: As the qualified person responsible for the work described above, I confirm that the appliance as associated work has been installed as per manufacturer’s instructions and following any applicable building and installation codes. Signed: ______________________________________ Print Name: __________________________________Date: ______________ Home Owner: RETAIN THIS INFORMATION FOR FUTURE REFERENCE © 2021 United States Stove Company...
- Page 4 Securely mount the blower to the heater with the two (2) of either corner of the appliance. screws and washers provided. Figure 6. Surround Installation SPRING SURROUND Slots in surround slide of rebox top © 2021 United States Stove Company...
- Page 5 ROOM WHERE THE APPLIANCE IS INSTALLED. 42” CAN. 1067 mm RESTRICTING COMBUSTION AIR WILL RESULT IN * = Canadian installations A LAZY FIRE WHICH CAUSES SOOT OR CREOSOTE requires 8” (204 mm) BUILDUP AND GREATLY REDUCES EFFICIENCY. © 2021 United States Stove Company...
- Page 6 REMOVE BRICKS or MORTAR from existing fireplace Protector when installing this unit. Canada 8” 204 mm Side 2. Chimney Size. Minimum chimney size is 6” (153 mm) diameter. Maintain a 15 ft. minimum overall © 2021 United States Stove Company...
- Page 7 If any of the following conditions are evident, a poor appliance performance and should be avoided. makeup air supply MUST be installed. © 2021 United States Stove Company...
- Page 8 MUST have a warning plate excessive smoke or burns slowly, it may be caused permanently installed in a visible location stating by the chimney top being lower than another part of © 2021 United States Stove Company...
- Page 9 3. The chimney must meet all minimum height requirements. 4. Never use a chimney to ventilate a cellar or basement. Contact your local building authority for approved methods of installation and any necessary permits and/ or inspections. © 2021 United States Stove Company...
- Page 10 CLEARANCES COMBUSTIBLE SURFACES SPECIFIED FOR THIS APPLIANCE. Garbage; • NEVER OPERATE WITH SECONDARY TUBES, 2. Lawn clippings or yard waste; FIBERBOARD, OR INSULATION REMOVED. 3. Materials containing rubber, including tires; 4. Materials containing plastic; © 2021 United States Stove Company...
- Page 11 • low energy yield therefore calculations using this heating value consider the heat going up the chimney as lost energy. Therefore, • blackened windows efficiency calculated using the lower heating value of • incomplete log combustion © 2021 United States Stove Company...
- Page 12 Build the fire After the first high burn load and the stove is well warmed directly on the firebrick. up, adjust the unit as needed for a medium or low burn setting. © 2021 United States Stove Company...
- Page 13 DIRECTLY ON THE FIREBRICK. THIS APPLIANCE HAS NOT BEEN TESTED WITH THE USE OF ANY MEANS TO ELEVATE THE FIRE AND IT SHOULD NOT BE ATTEMPTED. • NEVER PUT WOOD ABOVE THE FIREBRICK LINING OF THE FIREBOX. © 2021 United States Stove Company...
- Page 14 Ashes should be placed in a metal operating temperatures. The secondary combustion container with a tight-fitting lid. The closed container of can only take place if the firebox is hot enough. © 2021 United States Stove Company...
- Page 15 4. Disconnect the flue gas pipe from the appliance. GASKET CARE 5. Slide appliance out to perform inspection. WARNING: NEVER OPERATE THE STOVE WITHOUT A GASKET OR WITH A BROKEN ONE. DAMAGE TO THE STOVE OR EVEN HOUSE FIRE MAY RESULT. © 2021 United States Stove Company...
- Page 16 Part numbers and descriptions can be found in the “Repair Parts” section of this manual. Once this information has been gathered you can contact customer service by phone 1-800-750-2723 Ext 5051 or Email parts@usstove.com. Model Information Model Number Serial Number © 2021 United States Stove Company...
- Page 17 Email to: parts@usstove.com IN ORDER TO MAINTAIN WARRANTY, COMPONENTS MUST BE REPLACED USING ORIGINAL MANUFACTURERS PARTS PURCHASED THROUGH YOUR DEALER OR DIRECTLY FROM THE APPLIANCE MANUFACTURER. USE OF THIRD PARTY COMPONENTS WILL VOID THE WARRANTY. © 2021 United States Stove Company...
- Page 18 Email to: parts@usstove.com IN ORDER TO MAINTAIN WARRANTY, COMPONENTS MUST BE REPLACED USING ORIGINAL MANUFACTURERS PARTS PURCHASED THROUGH YOUR DEALER OR DIRECTLY FROM THE APPLIANCE MANUFACTURER. USE OF THIRD PARTY COMPONENTS WILL VOID THE WARRANTY. © 2021 United States Stove Company...
- Page 19 Engineer Name: ____________________________________ Engineer Name: ____________________________________ License No.: ________________________________________ License No.: ________________________________________ Company: __________________________________________ Company: __________________________________________ Telephone No.: _____________________________________ Telephone No.: _____________________________________ Stove Inspected: Chimney Swept: Stove Inspected: Chimney Swept: Items Replaced: ____________________________________ Items Replaced: ____________________________________ © 2021 United States Stove Company...
- Page 20 All manuals and user guides at all-guides.com NOTES © 2021 United States Stove Company...
- Page 21 All manuals and user guides at all-guides.com...
- Page 22 All manuals and user guides at all-guides.com...
- Page 23 All manuals and user guides at all-guides.com...
- Page 24 All manuals and user guides at all-guides.com...
- Page 25 All manuals and user guides at all-guides.com...
- Page 26 All manuals and user guides at all-guides.com...
- Page 27 All manuals and user guides at all-guides.com...
- Page 28 All manuals and user guides at all-guides.com...
- Page 29 All manuals and user guides at all-guides.com...
- Page 30 All manuals and user guides at all-guides.com...
- Page 31 All manuals and user guides at all-guides.com...
- Page 32 All manuals and user guides at all-guides.com...
- Page 33 All manuals and user guides at all-guides.com...
- Page 34 All manuals and user guides at all-guides.com...
- Page 35 All manuals and user guides at all-guides.com...
- Page 36 All manuals and user guides at all-guides.com...
- Page 37 All manuals and user guides at all-guides.com...
- Page 38 All manuals and user guides at all-guides.com...
- Page 39 All manuals and user guides at all-guides.com...
- Page 40 All manuals and user guides at all-guides.com...