Airxcel Suburban SW4D Manuel D'installation, D'utilisation Et D'entretien page 7

12 V.D.C. ONLY
IF ANY OF THE ORIGINAL WIRE AS SUPPLIED WITH THE WATER
HEATER MUST BE REPLACED, IT MUST BE REPLACED WITH 18 GA.,
105°C WIRE OR IT'S EQUIVALENT.
HI-LIMIT
SWITCH
R
BL
JUNCTION
BOX
LIGHT
( FACTORY WIRING)
( ---- FIELD WIRING)
DISCONNECT POWER SUPPLY BEFORE SERVICING THERMOSTAT
AND HI-LIMIT UNDER ACCESS COVER.
CAUTION: DO NOT HI-POT (DIELECTIC HIGH VOLTAGE TEST) THIS
UNIT AFTER INSTALLATION. TO DO SO MAY CAUSE COMPONENT
DAMAGE AND VOIDS WARRANTY OF WATER HEATER.
Figure 5A: D, DE, DEM, DEC MODELS
120 V.A.C. ONLY
DISCONNECT POWER SUPPLY BEFORE REMOVING COVER
SUBURBAN MANUFACTURING COMPANY, DAYTON, TENNESSEE
120 V.A.C SINGLE PHASE - 1440 WATT ELEMENT - 60 CYCLE
TOTAL CONNECTED WATTS = 1440 - AMPS = 12
OPTIONAL
AC POWER
CORD / PLUG
BK
SWITCH
W
G
GROUNDING SCREW
IF ANY OF THE ORIGINAL WIRE AS SUPPLIED WITH THE HEATER MUST BE
REPLACED, IT MUST BE REPLACED WITH 14 GA. 105°C WIRE OR IT'S EQUIVALENT.
SI UN DES FILS ELECTIQUES LIVRES AVEC LE CHAUFFE-EAU DOIT ETRE
REMPLACE, UTILISER A CET EFFET UN FIL 14 GA. 105°C OU EQUIVALENT.
Figure 6A: DE, DEM, DEC MODELS
HOT
COLD
MODULE BD.
T'STAT
SPARK CABLE
1 3 4 6
ELECTRODE
R
BR
4 3 2 1
Y
GAS VALVE
BR BROWN
G
YELLOW
Y
G GREEN
BL BLUE
R RED
BK BLACK
CODE
BK
W
G
HI-
T'STAT
LIMIT
BK
BK
BK
ELECTRIC
ELEMENT
Figure 7
IF ANY OF THE ORIGINAL WIRE AS SUPPLIED WITH THE WATER HEATER
MUST BE REPLACED, IT MUST BE REPLACED WITH 18 GA., 105°C WIRE
OR EQUIVALENT.
SWITCH
(GAS)
BK
LIGHT
JUNCTION
SWITCH
(ELECTRIC)
DISCONNECT POWER SUPPLY BEFORE SERVICING THERMOSTAT
AND HI-LIMIT UNDER ACCESS COVER.
CAUTION: DO NOT HI-POT (DIELECTRIC HIGH VOLTAGE TEST) THIS
UNIT AFTER INSTALLATION. TO DO SO MAY CAUSE COMPONENT
DAMAGE AND VOIDS WARRANTY OF WATER HEATER.
*12VDC SIDE OF RELAY
340461
DISCONNECT POWER SUPPLY BEFORE REMOVING COVER
COLOR SUBURBAN MANUFACTURING COMPANY, DAYTON, TENNESSEE
120 V.A.C SINGLE PHASE - 1440 WATT ELEMENT - 60 CYCLE
BLACK
TOTAL CONNECTED WATTS = 1440 - AMPS = 12
WHITE
GREEN
OPTIONAL
AC POWER
BK
CORD / PLUG
*
RELAY
W
G
IF ANY OF THE ORIGINAL WIRE AS SUPPLIED WITH THE HEATER MUST BE
REPLACED, IT MUST BE REPLACED WITH 14 GA. 105°C WIRE OR IT'S EQUIVALENT.
SI UN DES FILS ELECTIQUES LIVRES AVEC LE CHAUFFE-EAU DOIT ETRE
REMPLACE, UTILISER A CET EFFET UN FIL 14 GA. 105°C OU EQUIVALENT.
340601
*120VAC SIDE OF RELAY
JACKET
ACCESS MODULE
BOARD
JUNCTION BOX
12 V.D.C.
7
12 V.D.C. ONLY
MODULE BD.
HI-LIMIT T'STAT
1 3 4
R
BR
R
BL
RELAY
O
Y
G
BOX
( FACTORY WIRING)
( ---- FIELD WIRING)
Figure 5B: DEL, DELC MODELS
120 V.A.C. ONLY
HI-
T'STAT
LIMIT
BK
BK
SWITCH
GROUNDING SCREW
Figure 6B : DEL, DELC MODELS
CONTROL HOUSING
HOT
MOTOR AID
COLD
Figure 8: DEM MODELS ONLY
SPARK CABLE
6
ELECTRODE
BK
3
4 2 1
GAS VALVE
BR BROWN
Y YELLOW
GREEN
G
BL BLUE
R RED
BLACK
BK
O ORANGE
340539
CODE COLOR
BK BLACK
W WHITE
G
GREEN
BK
BK
ELECTRIC
ELEMENT
340602
ACCESS HOLE
GAS SUPPLY
JUNCTION BOX
120 V.A.C.
1/2 FEMALE
PIPE FITTING