Publicité
Liens rapides
PORCELAIN LINED, STEEL TANK
RV WATER HEATERS
676 Broadway Street | Dayton, TN 37321 USA
423.775.2131 | www.Airxcel.com/Suburban
DIRECT SPARK IGNITION (DSI), ELECTRIC ELEMENT AND MOTOR AID MODELS:
SW4D | SW6D | SW10D | SW12D | SW16D (Direct Spark Ignition)
SW4DE | SW6DE | SW10DE | SW12DE | SW16DE (Direct Spark Ignition and Electric Element)
SW6DEC | SW10DEC | SW12DEC | SW16DEC (Direct Spark Ignition, Electric Element and Power Cord)
SW4DEL | SW6DEL | SW10DEL | SW12DEL | SW16DEL (Direct Spark Ignition, Electric Element and Relay)
SW6DELC | SW10DELC | SW12DELC | SW16DELC (Direct Spark Ignition, Electric Element, Relay and Power Cord)
SW6DEM | SW10DEM | SW12DEM | SW16DEM (Direct Spark Ignition, Electric Element, and Motor Aid)
WARNING
If the information in these instructions is not
followed exactly, a fire or explosion may result
causing property damage, personal injury or death.
-
Do not store or use gasoline or other
flammable vapors and liquids in the vicinity of
this or any other appliance.
WHAT TO DO IF YOU SMELL GAS
•
Evacuate all persons from the vehicle.
•
Shut off the gas supply at the gas container
or source.
•
Do not touch any electrical switch, or use any
phone or radio in the vehicle.
•
Do not start the vehicle's engine or electric
generator.
•
Contact the nearest gas supplier or qualified
service technician for repairs.
•
If you cannot reach a gas supplier or qualified
service technician, contact the nearest fire
department.
•
Do not turn on the gas supply until the gas
leak(s) has been repaired.
-
Installation and service must be performed
by a qualified installer, service agency or the gas
supplier.
PN: 205269
08-23-2019
INSTALLATION, OPERATION and
MAINTENANCE MANUAL
DIRECT VENT GAS RV WATER HEATER
FOR INSTALLATION IN RECREATIONAL
VEHICLES AND MOBILE HOUSING
FREEZE WARNING
Drain or fill with RV approved antifreeze if subject
to freezing temperatures when storing for winter.
WARNING
Installation of this appliance must be made in
accordance with the written instruction provided
in this manual.
No agent representative or
employee of Suburban or other person has the
authority to change, modify or waive any provision
of the instructions contained in this manual.
Improper
adjustment,
maintenance or installation can cause serious injury
or death.
Read and follow all instruction and precautions in this
manual. Installation and service must be performed
by a qualified service agency or the gas supplier.
AN ODORANT IS ADDED TO THE GAS USED BY THIS
WATER HEATER.
INSTALLER: AFFIX THESE INSTRUCTIONS TO OR
ADJACENT TO WATER HEATER.
THESE INSTRUCTIONS AND WARRANTY FOR FUTURE
REFERENCE.
ALL TECHNICAL AND WARRANTY QUESTIONS SHOULD
BE DIRECTED TO THE COMPANY LISTED ON THE
WARRANTY OR RATING PLATE WHICH CAME WITH
YOUR WATER HEATER.
MODELS:
ALL MODELS
alteration,
service,
OWNER: RETAIN
Publicité
Sommaire des Matières pour Airxcel Suburban SW4D
- Page 1 FOR INSTALLATION IN RECREATIONAL VEHICLES AND MOBILE HOUSING 676 Broadway Street | Dayton, TN 37321 USA 423.775.2131 | www.Airxcel.com/Suburban DIRECT VENT GAS RV WATER HEATER DIRECT SPARK IGNITION (DSI), ELECTRIC ELEMENT AND MOTOR AID MODELS: SW4D | SW6D | SW10D | SW12D | SW16D (Direct Spark Ignition)
-
Page 2: Safety Warnings
SAFETY WARNINGS CAUTION It is imperative that the water heater tank be filled with water before If possible, do not install the water heater so the vent can be covered or obstructed when any door on the trailer is opened. If this is not possible, then the travel of the operating the water heater. -
Page 3: Important
H. Install chocks, one on each side of water heater, as illustrated in Figure 3. CAUTION Attach door to frame as illustrated. J. Close the door so that the door latch protrudes through the slot in the door. Turn latch 90 degrees to fasten door. Before applying the 120 VAC power to the water heater junction box, be sure the K. - Page 4 OPERATING SAFETY INFORMATION THERMOSTAT AND MANUAL RESET ALL "D" Models (See Figure 12) FOR YOUR SAFETY, READ BEFORE LIGHTING The model water heaters listed above are equipped with a high temperature limit as a cut- WARNING off device located behind the rubber grommet identified as “A” in Figure 15. Temperatures above 180°F will cause manual reset button to trip shutting down main burner.
- Page 5 To obtain information on locating a local service agency, contact: time until you smell the chlorine. Let the RV sit for a few days and the chlorine should Suburban, An Airxcel Brand take care of the problem. Then you will need to take care of the chlorine. Remove the Customer Service Department chlorine by flushing the system with fresh water.
- Page 6 INNER COACH WALL LUR MUR DE LA VOITURE INTERIEUR FRAMING OUTER COACH WALL LE CADRAGE LA PEAU DE LA VOITURE EXTERNE FLOORING LE PLANCHEIAGE 4 & 6 GALLON MODELS A=12 3/4"+1/8"-0" B=12 3/4"+1/8"-0" 10, 12 & 16 GALLON MODELS A=16 3/8"±1/16" B=16 3/8"±1/16"...
- Page 7 12 V.D.C. ONLY 12 V.D.C. ONLY IF ANY OF THE ORIGINAL WIRE AS SUPPLIED WITH THE WATER IF ANY OF THE ORIGINAL WIRE AS SUPPLIED WITH THE WATER HEATER MUST BE REPLACED, IT MUST BE REPLACED WITH 18 GA., 105°C WIRE HEATER MUST BE REPLACED, IT MUST BE REPLACED WITH 18 GA., OR EQUIVALENT.
- Page 8 "Y" CONTROL HOUSING ILLUSTRATED SHOWING INSIDE OF HOUSING ENGINE LA BOÎTE DE COMMANDE LE MOTEUR ILLUSTRÉE, MONTRANT L'INTÉRIEUR DE LA BOÎTE GROMMET (GAS INLET) WATER HEATER INSERTED FROM OUTSIDE OF HOUSING LA BAGUE (L'ADMISSION LE CHAUFFE-EAU DE GAZ) INSÉRÉ DE L'EXTÉRIEUR DE LA BOÎTE "Y"...
- Page 9 CORRECT / CORRIGER INCORRECT / INEXACT BLUE OR BLUE/ORANGE WELL DEFINED PATTERN BLEU OU BLEU/ORANGE TYPE BIEN DEFINI YELLOW OR YELLOW/ORANGE ERRATIC PATTERN JAUNE OU JAUNE/ORANGE TYPE ERRATIQUE Figure 13 VENT TERMINAL AIR SUPPLY INLET AREA WHERE TERMINAL IS NOT PERMITTED CANADIAN INSTALLATIONS US INSTALLATIONS CANADIAN INSTALLATIONS...
- Page 10 Center to your location is the responsibility of the owner/user. A current listing of recommended service center may be obtained from Suburban’s website: www.Airxcel.com. If you cannot locate a recommended service center locally, the service agency chosen to perform warranty repairs must contact our Service Department at 423-775-2131 for authorization before making repairs.