Customer Support; Checklist; Problem: Ice Does Not Dispense When Rocking Chute Is Depressed; Problem: Dispenser Crushes Ice As It Dispenses - Welbilt MANITOWOC S160 Serie Manuel D'installation, D'utilisation Et D'entretien

Checklist

If a problem arises during operation of your dispenser,
follow the checklists below, before calling service.
Routine adjustments and maintenance procedures are
not covered by the warranty.

PROBLEM: ICE DOES NOT DISPENSE WHEN ROCKING CHUTE IS DEPRESSED

Problem
Dispenser does not operate.
Dispenser runs but does not dispense
ice.

PROBLEM: DISPENSER CRUSHES ICE AS IT DISPENSES

Problem
Dispenser crushes ice as it dispenses.

PROBLEM: ICE CONTINUES TO DISPENSE OR DISPENSES BY ITSELF

Problem
Dispenser agitates every 55 seconds.
Does ice continue to dispense after the
cup has been pulled away?
Does the ice dispense by itself without
anyone around the dispenser?
16
Section 5

Customer Support

Unplug unit before servicing or cleaning. Ice
dispenser bin contains parts that can move at any
time and will cause injury if hands are in the way.
Possible Cause
No electrical power to dispenser.
No ice in bin.
Possible Cause
The ice in the bin is not the proper
size and type.
Is the ice being used a full size piece
of ice, i.e., are cubes full, not
shallow, etc.?
Possible Cause
No jumper on the timer.
Does the gearmotor continue to run
during this time?
Does the dispenser do this at regular
intervals?
! Warning
To Correct
Plugged in?
Breaker tripped?
Check the cord and plug of the dispenser,
Replace cord set if wire is broken.
Add ice to bin, have ice machine checked.
To Correct
Replace with acceptable ice.
Adjust ice machine cube size. Refer to ice
machine Installation, Use and Care manual
for procedure.
To Correct
Call for Service.
Call for Service.
Call for Service.
Part Number 000007646 Rev02 5/20