Preventative Maintenance Instructions - Dexter Laundry T-30 Manuel De L'utilisateur

PREVENTIVE MAINTENANCE INSTRUCTIONS
DAILY
1. Clean the lint screen. Use a soft brush if necessary.
2. Check the lint screen for tears. Replace if necessary.
3. Clean lint from the lint screen compartment.
MONTHLY
1. Remove lint accumulation from the end bells of the motors.
2. Remove lint accumulation from front control area.
3. Remove lint and dirt accumulation from the top of the dryer and all areas above, below, and around the
burners and burner housing. Failure to keep this portion of the dryer clean can lead to a build-up of lint
creating a fire hazard.
QUARTERLY
1. Check the belts for looseness, wear, or fraying.
2. Inspect the gasket of the door glass for excessive wear.
3. Check tightness of all fasteners holding parts to support channel.
4. Check tightness of all set screws.
5. Inspect the impeller for tightness of the blades to hub.
6. Remove the air flow switch assembly and check the tumbler thru-bolts for tightness.
7. Grease the pivot pins and the tension arms where in contact with each other. (Where applicable)
SEMI-ANNUALLY
1. Remove and clean the main burners.
2. Remove all orifices and examine for dirt and hole obstruction.
3. Remove all lint accumulation. Remove the front panel and the lint screen housing and remove lint
accumulation.
4. Apply a few drops of oil to each spacer tube on the tension arm assembly. (Where applicable)
ANNUALLY
1. Check the intermediate pulley bearings for wear.
2. Check and remove any lint accumulation from the exhaust system.
3. Grease the bearings and the shaft of the intermediate drive pulley. Use an Alemite grease gun and
Molykote BR2-S grease. (Where applicable)
SERVICE PARTS
DRIVE BELT, MOTOR
DRIVE BELT, TUMBLER
LINT SCREEN FILTER
For service and parts information, contact your local Dexter agent. To find your local Dexter agent, use the
Distributor Locator at the website shown below. If a Dexter agent is not available, contact Dexter Laundry,
Inc. directly as listed below:
Mailing Address:
Website: www.dexter.com
8514-234-001 REV N page 40
T-30 T-50
9040-076-003 9040-076-006
9040-073-009 9040-073-011
9822-026-002 9822-026-001
2211 West Grimes Avenue
Fairfield, IA 52556
USA
PART NUMBER_________
T-80
9040-076-011
9040-073-012
9822-031-002
Phone: 1-800-524-2954
T-120
9040-076-008
9040-076-005
9822-033-001
_