Publicité
Les langues disponibles
Les langues disponibles
Crouse-Hinds
1. Safety instructions
For skilled electricians and trained
personnel in accordance with national
legislation, including the relevant
standards and, where applicable, in acc.
with IEC 60079-17 on electrical
apparatus for explosive atmospheres.
❒ The portable searchlight must not be
used in zone 0 or 20 hazardous areas!
❒ The temperature class marked on the
portable searchlight is to be observed!
❒ The portable searchlight may only be
opened or charged outside of
"hazardous areas"!
❒ Modifications to the lamp or changes of
its design are not permitted!
❒ The searchlight shall only be used for
its intended purpose and in perfect
condition!
❒ For replacing components, only
genuine CEAG spare parts may be
used!
❒ Repairs that affect the explosion
protection , may only be carried out by
CEAG or a qualified "electrician", and
must afterwards be checked by an
"expert"!
❒ Prior to initial operation, the portable
lamp must be charged in accordance
with the instructions included in section
5 (only rechargeable version)!
❒ Lamps fitted with NiCd accumulators
must not be stored without a recharge
for more than 6 months!
Observe the national safety rules and
regulations for prevention of accidents
as well as the following safety
instructions which are marked with an
(
) in these operating instructions!
2. Conformity with standards
This explosion protected portable searchlight
meets the requirements of EN 50014, EN
50019, EN 50020, EN 60598, the EC directive
"Equipment and protective systems intended
for use in potentially explosive atmospheres"
94/9 EC and "Electromagnetic compatibility"
(89/336/EEC).
It has been designed, manufactured and
tested according to the state of the art and to
EN 29001 (ISO 9001).
This portable searchlight is suitable for use in zone
1 and 2 hazardous areas acc. to IEC 60079-10.
3. Technical data
EC type examination
certificate:
PTB 99 ATEX 2063
Category of application:
II 2 G
Explosion category:
EEx e ib IIC T4
Approval of the production
quality assurance:
PTB 96 ATEX Q 001-1
LTungsten lamp:
3.75V 0.8/0.4A,
BA15d cap
Order No.:
2 2035 300 000 (5 pieces)
Battery insert:
3 NiCd accumulators
Rated capacity:
4 Ah
Order No.:
2 1118 020 000
Rated duration:
apx. 5 h
Permissible
ambient temperatures:
in general:
-25°C to +40°C
Specified data kept at
battery temperature:
-5°C to +30°C
Storage in original
packing:
-40°C to +60°C
Protection category to
EN 60529 (IEC 60529): IP 65
Insulation class to EN 60598
with battery operation: III
Dimensions
L x W x H (mm):
196 x 97 x 126
Weight:
apx. 1.7 kg
4. Description and application:
The handy shape of the HE 8 N EN handlamps
renders them particularly suitable for
inspection and maintenance duties as well as
for security patrols.
The handlamps are composed of three units:
1. Housing including the electrical insert
2. Bezel ring with protective glass and
reflector
3. Battery insert
By turning the bezel ring about two times (fig. 1,
item 2), the light can be focussed from wide
beam to spot light.
A rotary switch with three switch positions is
located on the carrying handle.
- ON (main beam)
- OFF
- ON (red signal light)
A rechargeable battery insert composed of 3 x
4 Ah NiCd accumulators serves as power
source.
In case of a broken filament or towards the
end of the main beam's duration , there will be
an automatic changeover to pilot light, thereby
preventing a sudden and total failure of light.
If the lamp's operation is continued with pilot
light, a safety circuit will switch off the pilot
light after apx. 0.5 h whereby the
accumulators' deep discharge is prevented.
The signal light is made up of four bright light
emitting diodes built into the reflector.
A two-colour LED (laterally arranged near the
handle) indicates the available duration and
thus the battery's charging status (fig. 3).
LED green:available duration > 75%
LED red:
available duration 33-75 %
LED off:
available duration < 33 %
Charging status:
<10%, automatic
changeover to
to pilot light
The lamp and the LG 483 charger, order No. 1
1540 000 483, combine to provide a portable
emergency light in non-maintained system mode.
5. Taking into operation
Prior to taking the lamp into operation, check
its correct functioning and perfect condition in
accordance with these operating instructions
and other applicable regulations!
The handlamp may be opened or
charged only outside of hazardous
areas!
Initial use:
Charging alternatives:
The HE 8 EURO PLUS portable lamp
(including rechargeable battery set) may only
be charged with the aid of the charger order
ref. 1 1518 000 111.
CEAG Sicherheitstechnik GmbH
4 4 4 4 4
Publicité
