Télécharger Imprimer la page

Publicité

Liens rapides

Owner's Instruction and Operation Manual
Model Number:
US5513-W
Report Number: F22-771
Certified to ASTM E1509-2022 and Certified to
CAN/ULC S627:2023; Complies to CAN ICES-
3(B)/NMB-3(B); Contains IC:23243-WBR1DIPEX
Mobile Home / Transportable Building Approved
* All Pictures In This Manual Are For Illustrative Purposes Only. Actual Product May Vary.
Save These Instructions In A Safe Place For Future Reference.
SAFETY NOTICE: If this heater is not properly installed, a house fire may result. For
your safety, follow the installation instructions. Never use make-shift compromises
during the installation of this heater. Contact local building or fire officials about
permits, restrictions and installation requirements in your area. NEVER OPERATE
THIS PRODUCT WHILE UNATTENDED.
CAUTION! Please read this entire manual before you install or use your new room
heater. Failure to follow instructions may result in property damage, bodily injury, or
even death. Improper Installation Will Void Your Warranty!
WARNING: Before starting your pellet stove remotely with WiFi, it is critical that you
ensure nothing is leaning, draped or near to your stove. All clearances to combustibles
specified in your owner's manual must be maintained at all times. Failure to comply
with this warning could result in a fire and or property damage.
U.S. Environmental Protection Agency
Certified to comply with 2020 particulate
emissions standards.
THIS MANUAL IS SUBJECT TO CHANGE WITHOUT NOTICE.
© 2023 United States Stove Company, 227 Industrial Park Rd., South Pittsburg, TN 37380
R
CALIFORNIA PROPOSITION 65 WARNING:
This product can expose you to chemicals including carbon
monoxide, which is known to the State of California to cause
cancer, birth defects, and/or other reproductive harm. For
more information, go to
853992-0704M
www.P65warnings.ca.gov
Ph. 800-750-2723

Publicité

loading

Sommaire des Matières pour United States Stove US5513-W

  • Page 1 State of California to cause cancer, birth defects, and/or other reproductive harm. For emissions standards. more information, go to www.P65warnings.ca.gov THIS MANUAL IS SUBJECT TO CHANGE WITHOUT NOTICE. © 2023 United States Stove Company, 227 Industrial Park Rd., South Pittsburg, TN 37380 Ph. 800-750-2723...
  • Page 2 / transportable building. Your stove is Certified to ASTM E1509-2022 and Certified to CAN/ULC S627:2023. This manual describes the installation and operation of the U.S. Stove, US5513-W wood heater. This heater meets the 2020 U.S. Environmental Protection Agency’s crib wood emission limits for wood heaters sold after May 15, 2020.
  • Page 3 Declaration of Completion: As the qualified person responsible for the work described above, I confirm that the appliance as associated work has been installed as per manufacturer’s instructions and following any applicable building and installation codes. Signed: ______________________________________ Print Name: __________________________________Date: ______________ Home Owner: RETAIN THIS INFORMATION FOR FUTURE REFERENCE © 2023 United States Stove Company...
  • Page 4 Harness to the top right-hand corner of the control panel. Connect the factory installed 7 Pin Com Cabel to the control panel directly below the 5 Pin Main Wiring Harness. 5 Pin Main Wiring Harness 7 Pin Com Cable © 2023 United States Stove Company...
  • Page 5 CORD IN FOOT TRAFFIC AREAS OR PINCH THE CORD UNDER FURNITURE. US Stove highly recommends your stove be installed by a qualified NFI (US) or WETT (Canada) technician. To find the nearest qualified installer, go to: https://nficertified.org, https://www.wettinc.ca/ © 2023 United States Stove Company...
  • Page 6 Wall to Stove 7-1/2” 191 mm Front to Stove 18” 458 mm Side Wall to PL Vent Pipe 11-1/4” 286 mm Wall to PL Vent Pipe 7-1/2” 191 mm Back to Flue 2” 51 mm © 2023 United States Stove Company...
  • Page 7 © 2023 United States Stove Company...
  • Page 8 D. Minimum 7-foot (2.13m) clearance from any grade interior of the home. Vent surfaces can get hot enough when adjacent to public walkways. © 2023 United States Stove Company...
  • Page 9 2. Install the wall thimble as specified by the structure, a 3” (76 mm) clearance should be maintained manufacturer (wall thimble sold separately). from the outside wall and a clean out tee should be 3. Install venting. © 2023 United States Stove Company...
  • Page 10 Bracket having jurisdiction before you have a qualified installer proceed with this installation. 3” to 6” Pipe Adapter To Stove 3” PL Vent Clean Out Tee © 2023 United States Stove Company...
  • Page 11 • The exhaust blower will start. Note that this appliance pulses the exhaust blower in order to achieve the proper air to fuel ratio, and to also aid in the cleaning of the burn pot. © 2023 United States Stove Company...
  • Page 12 INTO AN ELECTRICAL OUTLET. THESE MOVING PARTS MAY BEGIN TO MOVE AT ANY TIME Your pellet stove is designed to burn premium hardwood WHILE THE STOVE IS PLUGGED IN. pellets that comply with the Pellet Fuels Institute (PFI) © 2023 United States Stove Company...
  • Page 13 Press the “Display Button” to see the current heat burning results, refer to “Optimal Operation” section of range. Use the up and down arrows to adjust the heat this manual. range. T-stat Mode - Press the “Display Button” to © 2023 United States Stove Company...
  • Page 14 The stove • WE RECOMMEND YOU NOT LET THE HOPPER will shut down and show “E2” on the two digit display. DROP BELOW 1/4 FULL. The stove has to fully shut down before restarting. © 2023 United States Stove Company...
  • Page 15 Some regular vacuum cleaner Clean-Out (i.e. shop vacs) may leak ash into the room. DO NOT VACUUM HOT ASH. Plate WARNING: FAILURE TO PROPERLY MAINTENANCE THE CLEAN OUTS WILL RESULT IN POOR PERFORMANCE OF THIS STOVE. © 2023 United States Stove Company...
  • Page 16 To clean the ashes are disposed of by burial in soil or otherwise the chimney, disconnect the vent from the stove. locally dispersed, they should be retained in the closed © 2023 United States Stove Company...
  • Page 17 Animal Hopper (end of Empty & season) Vacuumed hair build up in blowers can result in poor performance or unforeseen safety hazards. © 2023 United States Stove Company...
  • Page 18 (18 in) beyond the appliance on any side equipped with a door, and at least 200 mm (8 in) beyond the appliance on DO NOT INSTALL IN AN ALCOVE other sides, shall be protected by a continuous, durable, DO NOT INSTALL IN ANY FIREPLACE © 2023 United States Stove Company...
  • Page 19 If the other items check out OK, replace the high limit switch. ATTENTION: THIS WOOD HEATER NEEDS PERIODIC INSPECTION AND REPAIR FOR PROPER OPERATION. IT IS AGAINST FEDERAL REGULATIONS TO OPERATE THIS WOOD HEATER IN A MANNER INCONSISTENT WITH OPERATING INSTRUCTIONS IN THIS MANUAL. © 2023 United States Stove Company...
  • Page 20 (you may want to remove the hose entirely off the stove and the air switch first and make sure it is clear). If you hear a click, the air switch is working. BE CAREFUL TOO MUCH VACUUM CAN DAMAGE THE AIR SWITCH. © 2023 United States Stove Company...
  • Page 21 The control board is not sending power to the POF There should be a 5-volt (approximately) current going to the thermodisc or other auger system components. POF thermodisc after the stove has been on for 10 minutes. © 2023 United States Stove Company...
  • Page 22 Remove the auger motor from the auger shaft and try to run the The auger motor has failed. unit. If the motor will turn the shaft is jammed on something. If the motor will not turn, the motor is bad. © 2023 United States Stove Company...
  • Page 23 Circuit board malfunction. board is fine. If there is NOT power being sent to the blower when it shuts off during operation, then you have a bad control board. © 2023 United States Stove Company...
  • Page 24 Check to see if a surge protector is being used on the stove. If not, recommend one to the consumer. High limit switch is malfunctioning. If the other items check out okay, replace the high limit switch. © 2023 United States Stove Company...
  • Page 25 Bad Pellets. (Applies to GLASS “SOOT’S” UP AT You might also want to try a brand that is made from a different A VERY FAST RATE Only) type of wood (softwood vs. hardwood). Different woods have different characteristics when being burned. © 2023 United States Stove Company...
  • Page 26 Email to: parts@usstove.com 80915 RTD Temperature Probe IN ORDER TO MAINTAIN WARRANTY, COMPONENTS MUST BE REPLACED USING ASHLEY PARTS PURCHASED THROUGH YOUR DEALER OR DIRECTLY FROM ASHLEY. USE OF THIRD PARTY COMPONENTS WILL VOID THE WARRANTY. © 2023 United States Stove Company...
  • Page 27                 Ensure the wires are connected to the bottom two prongs of the hopper switch as shown. CORRECT WRONG © 2023 United States Stove Company...
  • Page 28 Engineer Name: ____________________________________ Engineer Name: ____________________________________ License No.: ________________________________________ License No.: ________________________________________ Company: __________________________________________ Company: __________________________________________ Telephone No.: _____________________________________ Telephone No.: _____________________________________ Stove Inspected: Chimney Swept: Stove Inspected: Chimney Swept: Items Replaced: ____________________________________ Items Replaced: ____________________________________ © 2023 United States Stove Company...