Maintenance Instructions - Little Wonder OPTIMAX 9270-12-01 Manuel Du Propriétaire

Fiche technique
ET 04380
LITTLE
WONDER
BLOWER

MAINTENANCE INSTRUCTIONS

Stop engine and remove the spark plug wire before
performing any maintenance.
Keep blower air intake clear of debris for best
performance.
Clear air discharge area of any debris accumulation.
Ensure machine has been shut off and fan is no longer
moving before clearing.
Keep all hardware tight.
Check oil level daily. Top off as needed.
Change engine oil after the first 5 hours of operation.
Then change as recommended by the engine
manufacturer.
1. Remove drain plug and drain oil while engine is
warm.
2. Replace drain plug, remove fill plug and fill with
new oil. See engine manual for oil specifications.
3. Start and run engine for 30 seconds. Stop engine.
4. Wait 30 seconds, then re-check oil level.
5. Top off if necessary. See engine manual for
details.
PROTOUMAT - 35 route de Colmar, 67600 Sélestat
SIRET : 444 448 898 00015
Lubricate chains every 40 hours or weekly, whichever
comes first. Use a teflon containing chain lubricant
such as bicycle chain lube that does not attract
dirt. Bicycle chain lube is available at any bicycle
shop or most places where bicycles are sold. Slots
A are provided in the chain covers to allow chain
lubrication. Keeping the chains lubricated will greatly
extend the like of both the chains and the sprockets.
(Figure 1)
Lubricate the hex shaft/trunnion assembly once
a season or if moving the speed/direction lever
becomes difficult. A teflon containing lubricant such
as bicycle chain lube is recommended. To lubricate
the hex shaft the bottom cover must be removed and
the unit tipped up and to the right until it rests on the
housing. The bottom cover is held by two nuts on the
rear of the unit. (Figure 2)
Take care not to get any lubricant on either the drive
or the driven disc. Any lubrication on these parts
will cause slipping of the friction drive. Clean off any
lubricant that gets on the drive or driven parts.
FIGURE 1
MAINTENANCE
FIGURE 2
Tél. : 03 88 08 65 06
Fax : 03 88 08 67 39
13
contact@protoumat.fr
55
www.protoumat.fr