Table Des Matières - Pentair Water Pool and Spa MasterTemp 460792 Manuel D'utilisation Et D'installation

Table of Contents
Section 1. Heater Identification Information .......................................................................
Section 2. Introduction ..........................................................................................................
Important Notices .................................................................................................................................................................................
Warranty Information ............................................................................................................................................................................
Code Requirements ..............................................................................................................................................................................
Consumer Information and Safety Information ......................................................................................................................................
General Specifications .........................................................................................................................................................................
Section 3. Installation .............................................................................................................
Heater Description ................................................................................................................................................................................
Putting the Heater into Service ............................................................................................................................................................
Specifications ......................................................................................................................................................................................
Plumbing Connections ..........................................................................................................................................................................
Valves ..................................................................................................................................................................................................
Manual By-Pass ..................................................................................................................................................................................
Water Connections ...............................................................................................................................................................................
Below Pool Installation .........................................................................................................................................................................
Gas Connections .................................................................................................................................................................................
Sediment Traps ....................................................................................................................................................................................
Gas Pipe Sizing ...................................................................................................................................................................................
Testing Gas Pressure/Gas Pressure Requirements .............................................................................................................................
Outdoor Installation ..............................................................................................................................................................................
Outdoor Installation Venting Guidelines ................................................................................................................................................
Indoor Venting-General Requirements (Category I & Category III - clarification) ...............................................................................
Heater Clearances ................................................................................................................................................................................
Outside Vent Removal .........................................................................................................................................................................
Combustion Air Supply .........................................................................................................................................................................
Corrosive Vapors and Possible Causes ................................................................................................................................................
Vent Installation (Indoor Installation for U.S. or Outdoor Shelter for Canada) ........................................................................................
Vertical Venting - Negative Pressure ...................................................................................................................................................
Horizontal or Vertical Venting - Positive Pressure ................................................................................................................................
Connecting Special Gas Venting ..........................................................................................................................................................
Outdoor Shelter Vent Installation ..........................................................................................................................................................
Garage or Utility Room Installation .......................................................................................................................................................
Control Panel Indexing .........................................................................................................................................................................
Final Installation Check ........................................................................................................................................................................
Electrical Connections ..........................................................................................................................................................................
Fireman's Switch Connection/Remote Control Connections ..................................................................................................................
MasterTemp Wiring Diagram .................................................................................................................................................................
Electrical Schematic Ladder Diagram ...................................................................................................................................................
Section 4. Operation ...............................................................................................................
Basic System Operation ......................................................................................................................................................................
HSI (Hot-Surface Ignition) Lighting/Operation .......................................................................................................................................
Operating .............................................................................................................................................................................................
To Turn Off Gas to Appliance ...............................................................................................................................................................
Safety Controls ....................................................................................................................................................................................
Section 5. Troubleshooting ...................................................................................................
Initial Troubleshooting and Troubleshooting Chart .................................................................................................................................
Heater Will Not Fire Troubleshooting ....................................................................................................................................................
LED Diagnostics ..................................................................................................................................................................................
Burner / Heat Exchanger Troubleshooting ............................................................................................................................................
Section 6. Maintenance ..........................................................................................................
Care and Maintenance ..........................................................................................................................................................................
Pressure Relief Valve ...........................................................................................................................................................................
After Start-Up ......................................................................................................................................................................................
Spring, Fall and Winter Operation .........................................................................................................................................................
Maintaining Pool Temperature ...............................................................................................................................................................
Energy Saving Tips ..............................................................................................................................................................................
Chemical Balance ................................................................................................................................................................................
Replacement Parts ..............................................................................................................................................................................
Rev. C 10-5-07
3
4
5
5
5
6
6 - 8
8
9
9
9
10
11
11
11
12
12
13
13
14
15
16
17
18
18
18
19
19
20
20 - 22
23
23 - 25
26
26
27
27
28
29
30
31
32
32
32
33
33
34 - 36
37
37
38 - 41
42 - 43
44
45
45
45
46
46
47
47
47 - 48
49 - 53
P/N 472592