Service & Maintenance - pcl NEX2 Manuel D'utilisation

Service / Maintenance
There is no requirement to service the following items:
1. Pressure Transducer
2. Electric Control Board
If these are faulty they can only be
replaced by a competent person.
Please refer to an Authorised dealer.
Periodically

Check the hose.

Check the tyre connector.

Remove air input supply and tyre hose from the head.
Unscrew captive sintered filters from filter housings and
clean or replace.
Working safety instructions
Since the unit is not explosion-proof, the device should not be
installed in areas where explosions are possible. Consideration
must be given to the requirements relative to Hazardous Area
Standards for your region or country.
The unit is designed and built to the relevant basic health and
safety requirements of the EC.
This product can be dangerous if used
improperly. Children should not be
allowed to use this equipment, as
incorrect setting can allow tyre to be over
inflated and a subsequent tyre burst/
explosion can occur!
Each person who is involved with
installation, start-up, maintenance and the
operation of the unit must read and
understand the complete operating manual.
The PCL tyre inflators are exclusively approved for the
dispensing of air/N . Each use which doesn't follow this
2
purpose as well as modifications to the product will be
deemed to be improper use. The manufacturer is not liable
for damages caused by improper use, the risk lies solely
with the user.
www.pclairtechnology.com
NEXUS Generator Only user manual
Proper use of the product also implies
the observance of the manufacturers
instructions with regard to installation,
start-up, operation and maintenance.
All works concerning installation,
start-up, adjustment and maintenance
must be made by qualified staff. For the
operation of this tyre pressure inflator
the local safety and accident prevention
rules must be observed in all cases.
High Pressure air is stored within the
system.
Do not exceed the maximum air input
pressure.
Do not operate this product if tired or
under the influence of medication, drugs
or alcohol.
To avoid the risk of personal injury,
especially to the eyes, face or skin DO
NOT direct the air/N
person.
stream at any
2