Texas A/S SNOW KING 6521WDE Manuel page 20

MAINTENANCE/TROUBLESHOOT
Maintenance chart
Engine oil
Air cleaner
Sediment Cup
Spark plug
Spark arrester
Idle speed
Combustion chamber
Valve clearance
Fuel tank and strainer
Fuel line
Fault
The unit does not operate smoothly and
vibrates intensively
Engine does not run
Engine does not run smoothly
Drive power falls
The engine will not start or dies after a
short period of time
Inadequate or no ejection
The snow is not removed fully
Everytime
Check X
Change
Check X
Clean
Replace
Clean
Check
Clean
Replace
Clean
Check
Adjust
Clean
Check
Adjust
Clean
Check
Possible causes
Bolts loose
Auger unit mounting
loose
Throttle lever in wrong
position
Spark plug defective
Fuel tank empty
Fuel cock closed
Bad Fuel
Spark plug dirty
Clutch play too large
Drive Belt loose or
damaged
Choke in wrong
position
Spark plug Fouled
No fuel
Snow ejection until
blocked
Plow screw not turning
Shearing bolts
sheared
Skids maladjusted
1st month Every 3 month
X
X
Every 2 years (Replace if necessary)
Check bolts
Check auger unit mounting
Check setting
Replace spark plug
Top up fuel
Open fuel cock
Empty Fuel Tank and refill with Fresh
Fuel
Clean the spark plug
Adjust clutch cable
Replace Drive Belt
Contact authorized customer service
Check Choke setting
Clean or replace spark plug (electrode
spacing 0.6mm)
Top up fuel
Clean the snow ejection unit with a
solid object
Adjust Auger clutch cable
Replace shear bolts or contact
authorized customer service
Adjust the skids
Every 6 month Once year
X
X
X
X
X
X
X
X
X
Remedy