Pump Replacement - resideo AquaPUMP Mode D'emploi

PUMP REPLACEMENT

Use this cross-reference tool to meet your installation needs.
Resideo
Model Pump Speed
Length
High
Medium UP15-42FC
PC3F1558IUF00 6.5"
Low
High
PC3F2699IUF00 6.5"
Medium UP26-64F
Low
High
Medium
PC3F4344IUF00 8.5"
Low
The information in this table is based on publicly available information as of the date of this publication. Resideo is not liable if
information is found to be incorrect.
If the cross-referenced model uses a flow check valve, then use a flow check with the Resideo model as well.
TROUBLESHOOTING
Fault
Pump not running
Squealing noise
Loud noises [> 43 dB(A)]
Pump is hot
Table 4. Cross Reference for Pump Replacement
Grundfos
Single 3-Speed
Speed
UP-42F UPS15-58 High
UP-42F-FC UPS15-58-FC High
UPS15-58 Low
UPS15-58-FC Low
UP15-18F
UP15-18F-FC
UP26-96F UPS26-99 High
UP26-96F-FC UPS26-99-FC High
UP26-116F
UP26-116F-FC
UPS26-99 Low
UP26-99FC UPS26-99-FC Low
UP43-44F UPS43-44 High
UP43-44F-FC UPS43-44-FC High
UPS43-44 Med
UPS43-44-FC Med
UPS43-44 Low
UPS43-44-FC Low
Cause
No operating voltage
Rotor/shaft stuck
Air in the pump
Pump flow too high
Cavitation due to insufficient supply
pressure
Normal
AQUAPUMP™ 3-SPEED CIRCULATION PUMPS
Bell &
Taco Gossett
Single 3-Speed
Speed
005F 00R High NRF-22
007F 00R Med LR-20WR
008F
008F-IFC
005F-IFC 00R Low NRF9F/LW
006F NRF-25 Med
006F-IFC
007F-IFC
0011F NRF-36 Med
0011F-IFC NRF-45 Med
0013F H-41
0013F-IFC
0014F
0014F-IFC
NRF-33
HV
H-32
0010F 0010 Med NRF-33
0012F-IFC
0010F-IFC 0010 Low
Check the electrical system.
• Isolate the pump from the power supply.
• Remove the vent screw (see Fig. 9).
• Turn the shaft clockwise using a small screwdriver.
• Screw in the vent screw.
• Switch on the pump.
• Verify that water is in the system and the service
valves are open.
• Verify that the pump is installed so that the motor
shaft is horizontal (Fig. 5).
• Bleed the pump
Reduce the pump speed using the knob or button
• Check the operating pressure of the system.
• Verify that the circulator intake is near the expansion
tank. Relocate if necessary.
It is normal for the pump to feel hot as the cast iron will
get about as hot as the water.
5
Armstrong Wilo
Single 3-Speed
Speed
Astro 30 Star 16 Star S16 High
Astro 30-3
Astro 50-3
Astro 230C1
Star S16 Med
Star 5
S16 Low
E7 Star 30F S21 High
Astro 50 Star 32F
Astro 50-3
Star 17 FX S21 Med
Star S21 Low
E16
H32
Action
62-0383EFS—11