NightStick XPR-5561 Mode D'emploi

Instruction Manual
XPR-5561G
THE XPR-5561G IS APPROVED FOR USE
Bayco Products, Inc.
640 S. Sanden Blvd., Wylie, TX 75098
Model XPR-5561 Permissible Cap Lamp Assembly
APPROVAL No. 19-A160003-1
TESTED FOR INTRINSIC SAFETY IN METHANE-AIR MIXTURES ONLY
WARNINGS:
1) Only to be charged on the surface, or underground in accordance with the applicable
regulations pertaining to battery-charging stations (reference 30 CFR 75.340) with a Bayco
Products, Inc. Model 5560-CHGR2
2) Do not open in areas where permissibility is required.
Ex ia FLASHLIGHT FOR USE IN HAZARDOUS LOCATIONS
UL listed for use with Bayco Li-ion Battery Pack 5560-BATT
CLASS I DIV 1 GRPS A-D T4
CLASS II & III DIV1 GRPS E-G T135°C
CLASS I ZONE 0 AEx ia IIC T4 Ga
E 467756
CLASS I ZONE 0 Ex ia IIC T4 Ga
ID 4003544 I M1 Ex ia I Ma
II 1 G Ex ia IIC T4 Ga
INTRINSICALLY SAFE
SECURITE INTRINSEQUE
WARNING: Do not charge battery in a hazardous location
WARNING: Do not replace battery when an explosive
2575
atmosphere is present
WARNINGS - INTRINSICALLY SAFE
y Warning: To prevent ignition of a hazardous atmosphere, the XPR-5561G must only be
charged in an area known to be non-hazardous.
y Warning: Use only the approved Nightstick 5560-BATT Lithium-ion rechargeable
battery pack.
y Warning: To prevent ignition of a hazardous atmosphere, do not open the battery
compartment or attempt to exchange the battery pack while in the hazardous environment.
This task must ONLY be performed in an area known to be non-hazardous.
y Warning: Open the battery compartment on the XPR-5561G and replace the approved
Nightstick 5560-BATT Lithium-ion rechargeable battery pack in fresh air only. To maintain
IP rating, torque battery compartment screws to 3.5 in-lb.
y Warning: replacement of the Lithium-ion rechargeable battery pack must be performed
by a quallified technician only.
y Warning: Substitution of components may impair intrinsic safety.
SPECIAL INSTRUCTIONS FOR INTRINSIC SAFETY
For personal safety, always confirm the rating of any known hazardous or potentially
hazardous location where the XPR-5561G is to be used.
CAUTION
y Rechargeable Lithium-ion batteries must be used and charged properly. Improper use
can result in serious injury, fire, or death.
y Do not leave the battery in direct sunlight or use or store the battery inside cars in hot weather.
y Do not expose the battery to water or salt water, or allow the battery to get wet.
y Do not store the battery with metallic objects that may cause a short circuit.
y Immediately discontinue use of the battery if the battery emits an unusual smell, feels hot,
changes color, changes shape or appears abnormal in any way.
y Keep out of the reach of children.
CHARGING THE LIGHT
CHARGER INPUT: 12 VDC Max
WARNING: Use only the supplied 5560-CHGR2 Charger & approved Nightstick
Lithium-ion Rechargeable Battery Pack.
y The time required to charge the 5561 is conditional on the remaining charge left in the
Lithium-ion Rechargeable Battery Pack at the time of charging. The maximum charge time
required is approximately 6 hours.
Bayco Products, Inc. • 640 South Sanden Blvd. • Wylie, TX 75098 • USA • 1-800-233-2155 • 1-469-326-9400 • www.nightstick.com
y Fully charge the 5561 before the first use, or if the 5561 has been unused for several
months.
y When the 5561 is properly seated in the charger, the LED Charge Indicator light will
turn solid RED indicating that the Lithium-ion Rechargeable Battery Pack is charging. The
Lithium-ion Rechargeable Battery Pack is fully charged when the LED Charge Indicator
light turns GREEN.
y The Lithium-ion Rechargeable Battery Pack does not have any Recharge Memory
Effect; therefore placing the 5561 in the charger prior to full depletion of the battery does
not adversely affect the battery life. The 5561 can be kept in the charger indefinitely without
any negative impact on the battery or the battery life.
OPERATION
The XPR-5561G is controlled by 2 Switches and has 6 separate lighting modes:
y High-brightness Spotlight
y Low-brightness Spotlight
y Spotlight Beacon
y High-brightness Floodlight
y Survival-mode Floodlight
y Dual-Light (both the Spotlight and Floodlight on at the same time)
Spotlight Modes
To activate the spotlight, press and release the spotlight switch. The default mode will
be low-brightness. Press the spotlight switch a second time to activate the high-brightness
mode. To activate the spotlight beacon press and hold the spotlight button until the beacon
turns on. Press the spotlight switch a third time to turn the light off.
Floodlight Modes
To activate the floodlight, press and release the floodlight switch. The default mode will
be high-brightness. To select the survival mode, press the floodlight switch a second time.
Press the floodlight switch a third time to turn the light off.
Dual-Light Mode
Dual-Light mode allows the user to turn on both the spotlight and the floodlight at the
Ex ia I Ma same time. Dual-Light mode can be activated by simply pressing the spotlight switch and
then the floodlight switch. If the 5561 already has the spotlight or the floodlight on (regardless
Ex ia IIC T4 Ga
of what brightness mode that light is in), pressing the switch for the light that is NOT on,
DEMKO 17 ATEX 1826
will activate Dual-Light mode. The user can leave Dual-Light mode and go back to either
IECEx UL 17.0005
spotlight or floodlight mode simply by pressing the switch for the mode that they wish to turn
-20ºC ≤ Tamb ≤ +40ºC
off. To turn both lights off, simply press each of the switches independently.
3.7V/Cell Li-ion
Low Battery Warning
Um: 10V
The XPR-5561G has a Low Battery Warning feature. Once the battery charge falls below
2.9V, the Spotlight LED will blink once every minute while the light is on regardless of which
of the 5 modes the 5561 is in at the time. The Spotlight LED will continue to flash until the
battery is fully depleted or until the 5561 is recharged to have a remaining charge capacity
greater than 2.9V. This warning feature is an indication that the 5561 should be charged as
soon as is possible. If the 5561 is off, no such warning will take place.
WARRANTY
LIMITED LIFETIME WARRANTY
Bayco Products, Inc. warrants this product to be free from defects in workmanship and
materials for the original purchaser's lifetime. The Limited Lifetime Warranty includes the
LEDs, housing and lenses. Rechargeable batteries, chargers, switches, electronics and
included accessories are warranted for a period of two years with proof of purchase. Normal
wear and failures which are caused by accidents, misuse, abuse, faulty installation and
lightning damage are excluded.
We will repair or replace this product should we determine it to be defective. This is the
only warranty, expressed or implied, including any warranty of merchantability or fitness for
a particular purpose.
For a complete copy of the warranty, go to www.baycoproducts.com/bayco-product-
support/warranties. Retain your receipt for proof of purchase.
LA LAMPE XPR-5561G EST APPROUVÉE POUR UTILISATION
AVERTISSEMENTS – SÉCURITÉ INTRINSÈQUE
y Avertissement : Pour éviter l'inflammation d'atmosphère dangereuse, la lampe XPR-
5561G doit être uniquement charger dans une zone non dangereuse.
y Avertissement : Utiliser uniquement le bloc-piles approuvé et rechargeable au lithium-
ion Nightstick 5560-BATT.
y Avertissement : Pour éviter l'inflammation d'atmosphère dangereuse, ne pas ouvrir le
compartiment à piles ou essayer d'échanger le bloc-piles dans un endroit dangereux.
Cette tâche doit être effectuée UNIQUEMENT dans une zone non dangereuse.
y Avertissement : Ouvrir le compartiment à piles situé sur la lampe XPR-5561G et
remplacer le bloc-piles approuvé et rechargeable au lithium-ion Nightstick 5560-BATT au
grand air uniquement. Pour maintenir le classement IP, serrez les vis du compartiment de
la batterie à 3,5 po-lb.
INS-XPR-5561G-DL-21
Mode d'emploi
XPR-5561G
02-08-2021