Installing Lp Gas Tank - Blue Rhino Crossfire GBT1508B Manuel Du Propriétaire

10

Installing LP Gas Tank

When you choose to use propane, this grill is designed
to operate with a 1 lb. 7.75 in. or 10.6 in. high
disposable / 16.4 oz. or 14.1 oz. propane gas tank
(DOT 39 Cylinder) (Figure 1).
DO NOT ATTEMPT TO REFILL ANY 1 lb. (16.4 oz. or
14.1 oz.) PROPANE GAS TANKS!
Connecting LP Gas Tank
Only cylinders marked "propane" may be used.
Note: 1 lb cylinders may form frost when near empty.
1. Make sure the regulator/control knob is in the
" OFF" position (Figure 2).
2. Lubricate the threads of the regulator/control
knob with petroleum jelly. Line up threads on LP
gas tank with regulator/control knob.
3. Insert and rotate LP gas tank clockwise until
they fit snugly together. HAND TIGHTEN ONLY. Be
careful not to crossthread when screwing in tank
(Figure 3).
4. Perform leak test per "Checking for Leaks"
section.
Disconnecting LP Gas Tank
1. Turn the regulator/control knob to the " OFF"
position (Figure 2).
2. Rotate LP gas tank counterclockwise until it is
detached (Figure 4).
3. Store the LP gas tank in a proper location, per
instructions on the LP gas tank.
Operating Instructions
Checking for Leaks
Burner Connections
1. Make sure the regulator/control knob is securely
fastened to the burner.
Note: The brass nut should be 1/4 to 1/2 turn past
tight. The regulator will rotate 360º even when the
brass nut is tightened.
If your unit was assembled for you, visually check
the connection between the burner and regulator/
control knob (Figure 5).
W WARNING: Failure to inspect this
connection or follow these instructions
could cause a fire or an explosion
which can cause death, serious bodily
injury or damage to property.
2. If the burner and regulator/control knob do not
fit properly or if you have any questions, please
contact 1.800.762.1142 for assistance.
Tank/Gas Line Connection
1. Make 2-3 oz. of leak detection solution by mixing
one part liquid dishwashing soap with three parts
water.
2. Make sure regulator/control knob is in the
" OFF" position (Figure 2).
3. Apply the leak detection check solution on all "X"
locations (Figure 5).
a. If any bubbles appear, remove the LP gas tank and reconnect, making sure the
connection is secure.
b. If you continue to see bubbles after several attempts, remove the LP gas tank per
"Disconnecting LP Gas Tank" section, and contact 1.800.762.1142 for assistance.
c. If no bubbles appear after one minute, turn regulator/control knob to the " OFF"
position, wipe away solution and proceed.
First Use
1. Make sure all labels, packaging and protective films have been removed from the grill.
2. Remove manufacturing oils before cooking on this grill for the first time by operating
the grill for at least 15 minutes on (HIGH) with the lid closed. This will "heat clean" the
internal parts and dissipate odors.
Figure 1
1 lb
1 lb
465 g
453 g
3.875 in. / 9,8 cm
2.9 in. / 7,4 cm
Figure 2
Figure 3
Figure 4
Figure 5
X
X
Outdoor LP Gas Barbecue Grill
Model No. GBT1508B
Operating Instructions (continued)
Operating LP Gas Grill
Lighting Instructions
W WARNING: Always clean grill when switching from a charcoal grill to a
gas grill. Make sure burner ports are clean and clear from debris and
ashes.
W WARNING: NEVER use as an LP gas grill and charcoal grill at the same
time.
W CAUTION: Keep outdoor gas cooking appliance area clear and free
from combustible materials, gasoline and other flammable vapors and
liquids.
W CAUTION: Do NOT obstruct the flow of combustion and ventilation air.
W CAUTION: Check and clean burner/venturi tubes for insects and insect
nests. A clogged tube can lead to a fire.
W CAUTION: Attempting to light the
burner with the lid closed may cause
an explosion.
W CAUTION: Always open legs completely
and secure in place before opening lid
or lighting grill.
1. Open lid.
2. Check for obstructions of airflow to the burners.
Spiders, insects and webs can clog the burner/
venturi tube. A clogged burner/venturi tube can
lead to a fire.
3. Connect LP gas tank per "Connecting LP Gas
Tank" section.
4. Push and turn the control knob to (HIGH).
5. Press the (igniter) button and hold for up to 5
seconds to light burner.
6. If ignition does not occur in 5 seconds, turn
regulator/control knob to " OFF" position, wait 5
minutes and repeat lighting procedure.
7. If igniter does not light burner, use a lit match to
light burner manually.
a. Access the burner through the hole in bottom
bowl or side as indicated (Figure 6).
b. Turn the regulator/control knob to (LOW)
and position the lit match near side of the burner.
8. After lighting, observe the burner flame. Make sure all burner ports are lit and flame height
matches illustration (Figure 7).
W Caution: If burner flame goes out during operation, immediately turn
the regulator/control knob to " OFF" and open lid to let the gas clear
for 5 minutes before re-lighting.
Turning Off
1. Turn regulator/control knob to the " OFF" position (Figure 2).
Note: A "poof" sound is normal as the last of the LP gas is burned.
2. Disconnect LP gas tank per "Disconnecting LP Gas Tank" section.
Cooking
W CAUTION
: Do NOT leave grill unattended while preheating or burning off
(HIGH)
food residue on . If grill has not been cleaned, a grease fire can
occur.
1. Open lid and ignite the side burner per "Lighting Instructions" section.
2. Close lid and preheat grill on (HIGH).
3. Adjust regulator/control knob to desired flame height.
4. Wear protective gloves and use long handle tongs to place food onto cooking grids above
the lit burner.
5. With lid open or closed, cook until desired internal food temperatures are achieved.
6. Turn grill off per "Turning Off" section.
Operating Charcoal Grill
Lighting Instructions
W WARNING: NEVER use the gas grill to start the charcoal.
W WARNING: NEVER use the electronic ignition to start the charcoal.
W WARNING: Always disconnect and properly store the LP gas tank prior
to using as a charcoal grill.
W CAUTION: NEVER use charcoal that has been pre-treated with lighter
fluid. Use only a high grade plain charcoal, charcoal/wood mixture,
lump charcoal or cooking wood.
W CAUTION: Keep outdoor cooking appliance area clear and free from
combustible materials, gasoline and other flammable vapors and
liquids.
W CAUTION: Check to make sure the air vents are free of debris and ash
before using the grill.
Figure 6
Match
Figure 7
Flame Slight
Yellow
Slight
Blue
Burner
Dark
Blue