Publicité
Lubrication
What
When
Brake Levers
Every six months
Caliper Brakes
Every six months
Brake Cables
Every six months
Pedals
Every six months
Chain
Every six months
Torque force of screw and nut
is as follows
Nut model
M5
M6
M8
16
How
Put one drop of oil on the pivot point of
each brake lever. (Lubricant: Oil)
Put one drop of oil on the pivot point of
each caliper brake. (Lubricant: Oil)
Put four drops of oil into both ends of
each cable. Allow the oil to soak back
along the cable wire. (Lubricant:
Lithium based grease)
Put one drop of oil where the axles go
into the pedals. (Lubricant: Lithium
based grease)
Put one drop of oil on the each roller
of the chain. Wipe all excess oil off the
chain. (Lubricant: Chain lube or light
oil)
Torque value/unit
7 N.m
10.5 N.m
18 N.m
Mind to check if all bolts and nuts in the bike are firmly tightened on a regular
basis. You are suggested to tighten the bolts and nuts on relevant positions by
torque wrench according to the torque data in the following table.
Front wheel nuts
18-22
Rear wheel nuts
24-29
Seat binder nut
12-17
Seat tube nuts
7-9
Brake anchor nut
7-9
Handle bar cover plate nut
7-9
Head stem bolt
16-18
Crank cotter pin nuts
9-14
Brake center bolt
6-9
Important safety advice
• This bicycle arrives to you partially assembled, it must be completed by an adult.
• Children must be supervised when using this product.
• Always wear a helmet, elbow and knee pads when riding.
• Fully enclosed shoes should be worn. (No sandals or similar open shoes).
• This bicycle should be used on flat surfaces, away from traffic.
• Do not ride on wet surfaces, sand, gravel, dirt, leaves or muddy surfaces.
• Do not ride at night.
• Avoid high speeds and steep hills.
• Be cautious of pedestrians.
• Check all nuts and bolts before riding and tighten if necessary.
• Replace worn or faulty parts immediately.
• This product is for a child to learn balance on a two wheeled bike.
• It is not designed to withstand unusual loads, tricks or jumping.
• It is the responsibility of the owner to ensure this bike is properly assembled
before using.
N.m
N.m
N.m
N.m
N.m
N.m
N.m
N.m
N.m
17
Publicité
