PROFLO PF1604 Instructions D'installation

Installation Instructions
HET FMBO BOWL
With Pressure Assist
PF1604/ PF1605/ PF1606
Tools and Materials
• Screwdriver • Wrench
• Tape Measure • Level
• Drill • Flange
• Wax Seal • Marker
• Plugs • Screw Fixation
• Flexible • Adapter
1. Shut off water supply line to toilet. Flush
toilet and remove all water from the bowl
and tank. Use a sponge to absorb the water.
2. Disconnect the water supply from the tank.
3. Remove tank from bowl, use screw driver
and adjustable wrench or socket wrench.
Loosen toilet bowl flange nuts under caps.
4. Remove old bowl by carefully sliding it away
from the wall.
Install New Toilet
Make sure the closet flanged installed in the wall
is 4" above the floor. Assure the flange bolts
are installed correct, they should be parallel
perpendicular and 6" apart.
Install a neoprene seal or wax ring around the
bowl flange, (horn). Slide the bowl toward the
closet flange so the bolts project through the bowl
mounting holes.
Install the washers with, "This Side Up" toward you
and thread on nuts. Tighten the nuts alternating
from side to side.
DO NOT OVER TIGHTEN. VITREOUS CHINA
EASILY CRACKS.
Floor mounted, back outlet bowls must be fastened
to the floor with Lag Screws (not supplied).
Slip the plastic washer, marked side up, onto the
lag screw and screw into pre drilled pilot holes.
Install the washers, nuts, caps on the flange bolts
snug. Be careful not to over tighten.
Install the tank-to-bowl-gasket, tank bolts with
washer if it is not already installed, and place tank
on bowl.
Snug and level the tank nuts using a socket
wrench and holding the truss head screw firmly
inside the tank with a screwdriver.
Connect the water supply to the ballcock. Only
hand tighten the supply line.
© 2010 Ferguson Enterprises, Inc. All Rights Reserved
CHANNEL LOCKS. Turn on water, flush and
check for leaks. Follow PROFLO tank installation
instructions, (included), for proper adjustments
and connections.
Care & Maintenance
When installing this fixture please flush the
water supply line thoroughly before attach-
ing it to the tank. Refer to the Owner's Op-
eration and Installation Guide for additional
installation instructions.
Do not use abrasive powered or liquid clean-
ers which can damage the product surface.
Caution
Product is Fragile. To avoid Breakage and
possible injury handle with care!
Warranty
WHAT IS COVERED?
Ferguson Enterprises, Inc. "Ferguson" or the "Company"
warrants its products to be free from defects in material
and workmanship under normal use and service FOR
A PERIOD OF ONE (1) YEAR FROM THE DATE OF
INSTALLATION.
WHAT IS NOT COVERED?
The warranty set forth in paragraph 1 does not cover
installation or any other labor charges and does not apply
to products which have been damaged as a result of any
accident, abuse, improper installation or maintenance,
or modification of original plumbing product. The
warranty of such products is limited to the warranty
DO NOT USE
Distributed Exclusively by Ferguson and Wolseley Canada
extended to Ferguson by the product manufacturer.
Finally, FERGUSON SHALL NOT BE RESPONSIBLE
OR LIABLE FOR ANY FAILURE OR DAMAGE TO THIS
PRODUCT OR ANY COMPONENT THEREOF CAUSED BY
THE USE OF ABRASIVE CLEANERS.
HOW TO OBTAIN WARRANTY SERVICE
US Customers:
The purchaser should contact their local Ferguson
location, installing contractor or builder from whom the
product was purchased. To find you nearest Ferguson
location please visit www.ferguson.com and enter in
your address into the Find a Location field.
Canadian Customers:
The purchaser should contact their local Wolseley
Canada location, installing contractor or builder from
whom the product was purchased. To find your nearest
Wolseley Canada location please visit www.wolseleyinc.
ca, then click on Find a Location and enter your address
into the location field.
PROFLO is a registered trademark of Ferguson
Enterprises, Inc.
LIMITATIONS OF IMPLIED WARRANTY
DISCLAIMER OF CONSEQUENTIAL OR INCIDENTAL
DAMAGES FERGUSON DISCLAIMS ANY LIABILITY
FOR CONSEQUENTIAL OR INCIDENTAL DAMAGES AND
DISCLAIMS ALL EXPRESS OR IMPLIED WARRANTIES,
INCLUDING THOSE OF MERCHANTABILITY AND
FITNESS FOR A PARTICULAR PURPOSE, AS SET
FORTH ABOVE. IMPLIED WARRANTIES OF THE
PRODUCTS AND PRODUCT COMPONENTS SET
FORTH IN PARAGRAPH 1 ABOVE ARE LIMITED TO
THE DURATIONS OF THE RESPECTIVE WARRANTY.
Some states do not allow the exclusion or limitation
of incidental or consequential damages or limitations
on how long an implied warranty lasts, so the above
limitations may not apply to you. This warranty gives
you specific legal rights and you may also have other
rights, which vary from state to state.
AND
6635 01/11