Sommaire des Matières pour Samlex America SOLAR SRV-100-30A
- Page 1 All manuals and user guides at all-guides.com Solar owner's Please read this manual before Charging Kit Manual operating SrV-100-30A your kit SrV-150-30A...
- Page 2 CONSEQUENTIAL OR INCIDENTAL, WHICH MIGHT ARISE OUT OF THE USE OF SUCH INFORMATION. THE USE OF ANY SUCH INFORMATION WILL BE ENTIRELY AT THE USERS RISK. Samlex America reserves the right to revise this document and to periodically make changes to the content hereof without obligation or organization of such revisions or changes.
- Page 3 Indicates possibility of damage to the equipment in case of non-compliance. WARninG! Please read the owner's Manual carefully before attempting to carry out any installation and wiring. Contact your rV dealer or Technical support at Samlex America (1-800-561-5885) for any questions concerning the installation. installation and Wiring Compliance Installation and wiring must comply with the local and National electrical Codes and must be done by a certified electrician.
- Page 4 • Highest manufacturing standards - Test ID for each panel • Strong frame withstands high wind force Applications • residential roof-top Systems • Commercial / Industrial building roof-top Systems • rural area applications • other on-grid and off-grid applications • Automotive, rV and Marine 4 | SAMLEX AMERICA INC.
- Page 5 Temperature Coefficient of Current, Isc + 0.08% / °C + 0.05% / °C Temperature Coefficient of Voltage, Voc − 0.34% / °C − 0.33% / °C Temperature Coefficient of Power, Pmax − 0.43% / °C − 0.23% / °C SAMLEX AMERICA INC. | 5...
- Page 6 • 2 pieces for crimping to bare ends of battery wires for connection to Charge Controller (Srl. 3) (Inside Charge Controller SCC-30Ab box) Tapping Screw (#7x19 x 5/8”): Flat Head, Philips - For mounting of Charge Controller (Srl. 3) (Inside Charge Controller SCC-30Ab box) owner’s Manual for the Kit owner’s Manual for Charge Controller SCC-30Ab (Inside Charge Controller box) 6 | SAMLEX AMERICA INC.
- Page 7 Fig. 3.2: MC4 Female connector (marked “+”) 3. Strain Relief & Seal 4. Female Contact Insert 5. “Snap-in” type of locking tabs that slide inside locking slots (2) of the mating MC4 Female Connector (Fig 3.1) SAMLEX AMERICA INC. | 7...
- Page 8 To Charge connector marked (-) Controller Male MC4 mating connector marked (-) for Positive (+) PV Extension Wire Female MC4 mating connector marked (+) Fig 3.3. Connecting extension wires to the output wires of solar panel 8 | SAMLEX AMERICA INC.
- Page 9 Connecting Second Adjacent Solar Panel in Parallel (Fig. 3.4) SBC-2 Kit MC4 Female SCW-20-2 Kit Branch Connector (-) To external PV circuit MC4 Male Branch Connector (+) Fig. 3.4. Connecting two adjacent solar panels in parallel SAMLEX AMERICA INC. | 9...
- Page 10 The optional branch Connector “SbC-2” Kit is used to parallel the two solar panels. The second Connecting Wire Kit “SWC-20-2” is used to connect to the external PV circuit. 10 | SAMLEX AMERICA INC.
- Page 11 Controller ensuring correct polarity is observed (See Section 7). 8. Secure the solar panel to the rV roof (See Section 7). Solar Panel Solar Charge Controller Fuse within 7” of battery post Battery Fig. 4.1. installation Block Diagram Philips drive screw driver SAMLEX AMERICA INC. | 11...
- Page 12 10. After wiring the Charge Controller terminals (see Section 7 on wiring), fix the mounting plate to the installation surface using the screws provided with the Charge Controller (7 x 19, 5/8" flat Head Tapping Screws - Philips Drive). 12 | SAMLEX AMERICA INC.
- Page 13 (fig. 7.7). The Neoprene and brass resist most environmental conditions. ange 1/2” diameter 1/4” captive brass nut Fig. 7.3. Construction of a Well nut SAMLEX AMERICA INC. | 13...
- Page 14 ¼”-20 x 1¼” Flange Bolt Module ¼” Flat Washer RV roof material up to approx. 3/8” thickness Well-Nut Rubber bushing material expands when bolt is tightened to securely anchor hardware Fig. 7.8 Attaching 5-hole mounting bracket to RV Roof 14 | SAMLEX AMERICA INC.
- Page 15 2 pieces of ring Terminals (fig 8.2) have been provided for crimping on the wire ends on the battery side. • Use Inline ATC style fuse Holder of 10A ATC-10 fuse on the battery end of the Positive cable (fig 8.1; NOT SUPPLIED). The Fuse Holder comes with 4", AWG#12 pigtails. Splice one pigtail to the Positive wire end and use the other pigtail for battery connection. SAMLEX AMERICA INC. | 15...
- Page 16 & bare ends on the other side for connecting to the Charge Controller. The wires are marked (+) & and (-) for identification of the polarity. 4. Please read Section 3 on connecting PV extension Wires to the panels. 16 | SAMLEX AMERICA INC.
- Page 17 Positive terminal (marked “PV +”) of the Charge Controller and the Negative PV lead is connected to the Negative terminal (marked “PV -”) of the Charge Controller. Reverse polarity connection may damage the Charge Controller and the resulting damage will not be covered by warranty. SAMLEX AMERICA INC. | 17...
- Page 18 Negative terminals of batteries 1 to 4 are paralleled (connected together) and this common Negative connection becomes the Negative terminal of the 12V battery bank. PV + PV - BAT + 6V Battery 6V Battery 6V Battery 6V Battery BAT - 18 | SAMLEX AMERICA INC.
- Page 19 • All the individual batteries will charge at the same charging current and thus, will be charged to the same state at the same time. • None of the batteries will see an overcharge condition. SAMLEX AMERICA INC. | 19...
- Page 20 • Check and maintain battery electrolyte levels at regular intervals as per battery manufacturer’s recommendations if flooded/wet cell Lead Acid batteries are used. • Check and replace damaged components, if necessary. 20 | SAMLEX AMERICA INC.
- Page 21 11 | warranty The Samlex Solar Charging Kits (SrV-100-30A & SrV-150-30A) manufactured by Samlex America, Inc. (the “Warrantor“) are warranted to be free from defects in workmanship and materials under normal use and service. The warranty is in effect from the date of purchase by the user (the “Purchaser“).
- Page 22 All manuals and user guides at all-guides.com contact Information Toll free Numbers Ph: 1 800 561 5885 fax: 1 888 814 5210 Local Numbers Ph: 604 525 3836 fax: 604 525 5221 Website www.samlexamerica.com USA Shipping Warehouses Kent, WA Plymouth, MI Canadian Shipping Warehouse Delta, bC email purchase orders to...
- Page 23 All manuals and user guides at all-guides.com...
- Page 24 All manuals and user guides at all-guides.com...
- Page 25 All manuals and user guides at all-guides.com...
- Page 26 All manuals and user guides at all-guides.com...
- Page 27 All manuals and user guides at all-guides.com...
- Page 28 All manuals and user guides at all-guides.com...
- Page 29 All manuals and user guides at all-guides.com...
- Page 30 All manuals and user guides at all-guides.com...
- Page 31 All manuals and user guides at all-guides.com...
- Page 32 All manuals and user guides at all-guides.com...
- Page 33 All manuals and user guides at all-guides.com...
- Page 34 All manuals and user guides at all-guides.com...
- Page 35 All manuals and user guides at all-guides.com...
- Page 36 All manuals and user guides at all-guides.com...
- Page 37 All manuals and user guides at all-guides.com...
- Page 38 All manuals and user guides at all-guides.com...
- Page 39 All manuals and user guides at all-guides.com...
- Page 40 All manuals and user guides at all-guides.com...
- Page 41 All manuals and user guides at all-guides.com...
- Page 42 All manuals and user guides at all-guides.com...
- Page 43 All manuals and user guides at all-guides.com...
- Page 44 All manuals and user guides at all-guides.com...