Table des Matières
Publicité
Les langues disponibles
Les langues disponibles
Liens rapides
Remote Cable Cutters
52056897 REV 3
INSTRUCTION MANUAL
SDG45
SDG55
SDG85 (shown)
SDG105
Read and understand all of the instructions and
safety information in this manual before operating
or servicing this tool.
Register this product at www.greenlee.com
© 2013 Greenlee Textron Inc.
SDK105
Español ................. 7
Français .............. 13
4/13
Publicité
Chapitres
Table des Matières
Dépannage
Manuels Connexes pour Textron Company GREENLEE SDG45
Sommaire des Matières pour Textron Company GREENLEE SDG45
- Page 1 INSTRUCTION MANUAL SDG45 SDK105 SDG55 SDG85 (shown) SDG105 Español ....7 Français ....13 Remote Cable Cutters Read and understand all of the instructions and safety information in this manual before operating or servicing this tool. Register this product at www.greenlee.com 52056897 REV 3 ©...
-
Page 2: Table Des Matières
All specifications are nominal and may change as design • Battery Pump improvements occur. Greenlee Textron Inc. shall not be liable for EHP700L damages resulting from misapplication or misuse of its products. Greenlee / A Textron Company 4455 Boeing Dr. • Rockford, IL 61109-2988 USA • 815-397-7070... -
Page 3: Important Safety Information
Failure to observe this warning could result in severe injury or death. KEEP THIS MANUAL Greenlee / A Textron Company 4455 Boeing Dr. • Rockford, IL 61109-2988 USA • 815-397-7070... - Page 4 Do not cut cable under tension. Cable could fall or strike nearby personnel when cut. Greenlee / A Textron Company 4455 Boeing Dr. • Rockford, IL 61109-2988 USA • 815-397-7070...
-
Page 5: Specifications
EHS Guy Strand ......9/16" (14 mm) dia. 3/4" Ground Rod .......3/4" (19 mm) dia. Rebar (Schedule 60) ......5/8" (16 mm) dia. Soft Steel Bolts .........3/4" (19 mm) dia. Greenlee / A Textron Company 4455 Boeing Dr. • Rockford, IL 61109-2988 USA • 815-397-7070... -
Page 6: Setup
Check hydraulic fluid level. Add fluid if necessary Cutter jaws do not overlap at least Worn or damaged cutter jaws. Replace the cutter jaws. 0.030" (0.76 mm) on the centerline. Greenlee / A Textron Company 4455 Boeing Dr. • Rockford, IL 61109-2988 USA • 815-397-7070... -
Page 7: Spanish
MANUAL DE INSTRUCCIONES SDG45 SDK105 SDG55 SDG85 (ilustrada) SDG105 Cortacables hidráulicos Lea y entienda todas las instrucciones y la información sobre seguridad que aparecen en este manual antes de manejar esta herramienta o darle mantenimiento. Registre este producto en www.greenlee.com 52056897 REV 3 ©... -
Page 8: Descripción
Greenlee Textron Inc. no se hace • Bomba operada por batería responsable de los daños que puedan surgir de la mala aplicación o EHP700L mal uso de sus productos. Greenlee / A Textron Company 4455 Boeing Dr. • Rockford, IL 61109-2988 USA • 815-397-7070... -
Page 9: Importantes Información Sobre Seguridad
De no observarse esta advertencia podrían sufrirse graves lesiones o incluso la muerte. CONSERVE ESTE MANUAL Greenlee / A Textron Company 4455 Boeing Dr. • Rockford, IL 61109-2988 USA • 815-397-7070... - Page 10 No corte un cable bajo tensión. Al cortarlo, el cable podría caerse o golpear al personal circundante. Greenlee / A Textron Company 4455 Boeing Dr. • Rockford, IL 61109-2988 USA • 815-397-7070...
-
Page 11: Especificaciones
Varilla a tierra de 1,9 cm .... 19 mm (3/4 pulg.) dia. Barra de refuerzo (60)....16 mm (5/8 pulg.) dia. Pernos de acero dulce ....19 mm (3/4 pulg.) dia. Greenlee / A Textron Company 4455 Boeing Dr. • Rockford, IL 61109-2988 USA • 815-397-7070... -
Page 12: Instalación
Las tenazas no se superponen por Las tenazas del cortador están Reemplace las tenazas. lo menos 0,76 mm (0,030 pulg.) dañadas o desgastadas. sobre la línea central. Greenlee / A Textron Company 4455 Boeing Dr. • Rockford, IL 61109-2988 USA • 815-397-7070... -
Page 13: French
MANUEL D’INSTRUCTIONS SDG45 SDK105 SDG55 SDG85 (illustrée) SDG105 Têtes coupe-câble hydrauliques Assurez-vous lire attentivement et de bien comprendre les instructions suivantes avant d’utiliser ou de procéder à l’entretien de cet outil. Enregistrez votre produit en ligne, www.greenlee.com 52056897 REV 3 ©... -
Page 14: Sécurité
Greenlee Textron Inc. ne peut être tenue responsable des dommages résultant d’une application inappropriée ou d’un mauvais usage de ses produits. Greenlee / A Textron Company 4455 Boeing Dr. • Rockford, IL 61109-2988 USA • 815-397-7070... -
Page 15: Consignes De Sécurité Importantes
à immédiatement un docteur. l’entretien de cet outil. L’inobservation de cette consigne pourrait entraîner des blessures graves, voire mortelles. CONSERVER CE MANUEL Greenlee / A Textron Company 4455 Boeing Dr. • Rockford, IL 61109-2988 USA • 815-397-7070... - Page 16 Ne pas couper un câble sous tension. Le câble risque de tomber ou de frapper une personne à proximité lorsqu’il est coupé. Greenlee / A Textron Company 4455 Boeing Dr. • Rockford, IL 61109-2988 USA • 815-397-7070...
-
Page 17: Caractéristiques
à armure d'acier doux) . 105 mm (4,13 po) Barre d'armature (nomenclature 60) ...... 16 mm (5/8 po) dia. Boulons en acier doux ....19 mm (3/4 po) dia. Greenlee / A Textron Company 4455 Boeing Dr. • Rockford, IL 61109-2988 USA • 815-397-7070... -
Page 18: Installation
Les mâchoires de coupe ne se Mâchoires de coupe usées Remplacer les mâchoires de coupe. chevauchent pas sur au moins 0,76 mm ou endommagées. (0,030 po) sur la ligne centrale. Greenlee / A Textron Company 4455 Boeing Dr. • Rockford, IL 61109-2988 USA • 815-397-7070... -
Page 19: Illustrations And Parts Lists
Decal, cut hazard ........1 Coupler cap ..........1 50071637 Cylinder ..........1 52065151 Carrying bag .........1 52065525 Decal, identification ......1 52065823 Coupler kit, 3/8 male (includes 5–8) Seal ............1 Greenlee / A Textron Company 4455 Boeing Dr. • Rockford, IL 61109-2988 USA • 815-397-7070... - Page 20 Plate kit (includes 12, 13, 17, 18, 20) Screw ............4 52065826 Blade kit (includes 8, 9, 14) Snap ring..........2 52065825 Fastener kit (includes 3, 5, 10, 11, 14–16, 19, 21) Greenlee / A Textron Company 4455 Boeing Dr. • Rockford, IL 61109-2988 USA • 815-397-7070...
- Page 21 Piston backup ring 52065151 Carrying bag .........1 (included in 52054906) ......1 52065823 Coupler kit, 3/8 male (includes 9–12) O-ring (included in 52054906) ....1 52057001 Cylinder ..........1 Greenlee / A Textron Company 4455 Boeing Dr. • Rockford, IL 61109-2988 USA • 815-397-7070...
- Page 22 Plate kit (includes 9, 10, 15, 16, 18, 26) Pin guide ..........1 52065829 Spring kit (includes 1–6, 21) Frame plate ...........2 52065828 Fastener kit (includes 7, 8, 11–13, 17, 19, 20, 24) Greenlee / A Textron Company 4455 Boeing Dr. • Rockford, IL 61109-2988 USA • 815-397-7070...
- Page 23 (included in 52054906) ......1 Coupler cap ..........1 O-ring, 28.17 x 3.53 52065151 Carrying bag .........1 (included in 52054906) ......1 52065823 Coupler kit, 3/8 male (includes 8–11) Greenlee / A Textron Company 4455 Boeing Dr. • Rockford, IL 61109-2988 USA • 815-397-7070...
- Page 24 Adapter disk ..........1 52060699 Plate kit (includes 4–9) Spring cup ..........1 52060700 Spring kit (includes 10–16) Spring ...........1 52060701 Fastener kit (includes 3, 17–26) Disc ............1 Greenlee / A Textron Company 4455 Boeing Dr. • Rockford, IL 61109-2988 USA • 815-397-7070...
- Page 25 Decal, identification ......1 50067796 Piston ............1 Coupler cap ..........1 52065201 Cylinder ..........1 Male coupler, 3/8 ........1 52065151 Carrying bag .........1 52065823 Coupler kit, 3/8 male (includes 5–8) Greenlee / A Textron Company 4455 Boeing Dr. • Rockford, IL 61109-2988 USA • 815-397-7070...
- Page 26 Plate kit (includes 4–9) End cap ..........1 52065150 Spring kit (includes 10–14) Spring, 40 mm ........2 52065181 Fastener kit (includes 2, 15–23) Cylinder sleeve........1 Blade holder ..........1 Greenlee / A Textron Company 4455 Boeing Dr. • Rockford, IL 61109-2988 USA • 815-397-7070...
- Page 27 52056891 Decal, identification ......1 50067796 Piston ............1 52025832 Decal, cut hazard ........2 Backup ring (included in 52054906) ..1 52065823 Coupler kit, 3/8 male (includes 8–11) Greenlee / A Textron Company 4455 Boeing Dr. • Rockford, IL 61109-2988 USA • 815-397-7070...
- Page 28 Remote Cable Cutters Cutting Head Assembly Illustration and Parts List—SDK105 Part No. Description Part No. Description 52046703 Pivot pin ..........1 Screw ............1 Attachment block ........1 52046705 Piston rod..........1 52020511 Spring ...........1 52046707 Double fork ...........2 Pin ............4 52046706 Cylinder sleeve........1 Retaining ring ........8 52020638 Tubing ...........1...