Movexx T2500-P Manuel page 32

4. INSTRUCTIONS
Maintenance personal should always...
• completely read this manual and understand everything written in this manual
before he/she starts to work with the machine. In case of any doubt he/she
has to contact the supervisor and/or manufacturer or supplier.
• be 16 years or older.
• be absolutely capable to use this machine.
• choose a position that he/she can not be trapped or run over by the machine.
• never change the by the supplier placed securities or the implementations.
• uses the prescribed protective clothing, protective footwear etc.'
• uses safety goggles made of acid-resistant material
• uses protective gloves which reach the elbows, made of acid-resistant material
Batteries: Ensure regular recharging of batteries. The batteries installed are sealed, and are
maintenance free.
Do Not open these battery-pack or batteries.
Gear box: The gearbox/Transmission are sealed and do not require service. Check the oil level
every 3 months.
Brakes: The electro-magnetic braking does not require regular maintenance. Check once a year
the space in the friction disk. It need to be 0,15 mm.
Engine: The only part of the engine that needs maintenance are the brushes. You have to check
them once a year, and replace them every 4 year.
Motor Controller: This unit is only serviceable by Movexx or your authorised dealer.
Throttle lever: The lever and cable don't require maintenance. Should the lever or cable be da-
maged, these should be replaced.
Fuses: The control circuit is protected against inadvertent current overload. These fuses are
located at the controller under the cover.
Gear belt drive: The tension of the gear belts should be checked every six months. It must be
possible to push the gear belts down by about 1 cm. (Too tight will damage the drive shaft. Too
loose may cause the belts to come off)
datasheet Movexx T1000
manual Movexx T2500-P
Manual T2500-P
EN
14